Mercury Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2002 Mercury
| Mercury Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2002 Cougar | Not Tested | Not Tested |  | | Not Tested |
| 2002 Grand Marquis |  | |  | | |
| 2002 Mountaineer | | | | |  |
| 2002 Sable | | | | | |
| 2002 Sable | | | | | |
| 2002 Sable | | | Not Tested | Not Tested | |
| 2002 Villager | | | | | |
Service Bulletins for 2002 Mercury
| 2002 MERCURY COUGAR | |
|---|---|
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 01211 | |
| SOME VEHICLES MAY EXHIBIT CONDENSATION IN THE HEADLAMPS. *TT | |
| Bulletin Number: 01224 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE DEFROSTER GRILLE EDGES LIFT OUT OF THE DASH PAD. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 0224 | |
| SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0 | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031514 | |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY BE ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) P1380, P1381, P1383, AND/OR P0340 MAY BE STORED IN MEMORY. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 041814 | |
| STEERING COLUMN SHIPPED WITHOUT CRUSH PAD - REUSE ORIGINAL CRUSH PAD IF NOT DAMAGED. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04N02 | |
| ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS AS A RESULT OF CONTAMINATION OF THE FUEL PUMP. THIS PROGRAM EXTENDS THE COVERAGE OF THE FUEL DELIVERY MODULE (FDM). *TT *MJ | |
| Bulletin Number: 15482 | |
| SOME VEHICLES EQUIPPED WITH A DURATEC ENGINE MAY EXPERIENCE ENGINE DAMAGE AS A RESULT OF MICROSCOPIC INTERNAL CRACKS IN A BATCH OF INTAKE VALVES. *TT | |
| Bulletin Number: 15636 | |
| CONCERN WITH HEADLAMPS AND/OR INSTRUMENT PANEL LAMPS DIMMING SLIGHTLY AT IDLE. *TT | |
| Bulletin Number: 15750 | |
| SOME COUGARS MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS AND / OR STEERING SYSTEM LEAKS. *TT | |
| Bulletin Number: 15797 | |
| SOME VEHICLES MAY EXHIBIT A BUZZING NOISE COMING FROM THE DASH NEAR THE CLIMATE CONTROL SYSTEM WITH LESS THAN 6 MONTHS OF SERVICE. *TT | |
| Bulletin Number: 15828 | |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT | |
| Bulletin Number: 15830 | |
| BATTERY LAMP ON, HOWEVER THE CHARGING SYSTEM IS FUNCTIONING PROPERLY. *TT | |
| Bulletin Number: 15907 | |
| SUBJECT REGARDING WIPER BLADE EDGE GUARD PROTECTORS. *TT | |
| Bulletin Number: 16028 | |
| SOME VEHICLES EQUIPPED WITH A 2.5L ENGINE MAY EXHIBIT MULTIPLE MISFIRE DIAGNOSTIC TROUBLE CODES WITH NO DRIVEABILITY CONCERNS NOTED. *TT | |
| Bulletin Number: 16306 | |
| COOLANT LAMP ILLUMINATED AFTER CLUSTER REPLACEMENT. *TT | |
| Bulletin Number: 16528 | |
| HESITATION/SURGE DURING ACCELERATION BETWEEN 3000-4000 RPM. OASIS. *TT | |
| Bulletin Number: 16794 | |
| HESITATION / SURGE ON STEADY ACCELERATION BETWEEN 3000 AND 4000 RPM. *TT | |
| Bulletin Number: 17582 | |
| DIAGNOSTIC TROUBLE CODE P1000 (OBD SYSTEMS READINESS TEST NOT COMPLETE) RESETTING AFTER IT HAS ALREADY CLEARED. *TT | |
| 2002 MERCURY GRAND MARQUIS | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01213 | |
| VEHICLES MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 02136 | |
| ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02175 | |
| RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0254 | |
| ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER PUMP PULLEY WHENTHE BELT IS SPLASHED WITH WATER. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0274 | |
| SOME VEHICLES MAY EXHBIT A SQUEAK / CREAK NOISE COMING FROM THE LEFT FRONT OR RIGHT FRONT DOOR HINGE AREA. *TT | |
| Bulletin Number: 0297 | |
| SOME VEHICLES PRODUCED BEFORE 3/5/2002 MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03157 | |
| GRINDING TYPE NOISE FROM THE TIMING CHAIN AREA. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03193 | |
| EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03228 | |
| LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03261 | |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042407 | |
| NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DTCS, SUCH AS C1145, C1155, C1165, C1175, C1296, C1297, C1298, C1299 AND C1222. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04247 | |
| NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DIAGNOSTIC TROUBLE CODES (DTCS). *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15158 | |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH | |
| Bulletin Number: 15415 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION BETWEEN 1100-1300 RPM WHEN THE TRANSMISSION IS PLACED IN EITHER PARK OR NEUTRAL. *TT | |
| Bulletin Number: 15668 | |
| CONCERNS WITH HESITATION/STUMBLE , COLD ONLY , WHEN SHIFTING FROM PARK TO DRIVE OR PARK TO REVERSE. *TT | |
| Bulletin Number: 15802 | |
| ON SOME VEHICLES THE HEADLAMPS REMAIN ILLUMINATED WHEN WIPERS ARE ACTIVATED AND THEN DEACTIVATED. *TT | |
| Bulletin Number: 15808 | |
| SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT | |
| Bulletin Number: 15812 | |
| OVERSPEED WARNING CHIME ACTIVATION WHEN TRAVELLING ABOVE 70 M PH / 110 KPH. *TT | |
| Bulletin Number: 15875 | |
| SOME RETAIL CUSTOMERS MAY PERCEIVE THE OPERATION OF THE DASH LIGHT DIMMING FEATURE AS BEING FAULTY. *TT | |
| Bulletin Number: 15881 | |
| SUBJECT REGARDING ENGINE STUMBLE / HESITATION COLD ONLY CONDITION. *TT | |
| Bulletin Number: 15893 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ENGINE COOLING FAN. *TT | |
| Bulletin Number: 16068 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT 1100-1500 RPM. *TT | |
| Bulletin Number: 16380 | |
| SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS. *TT | |
| Bulletin Number: 16401 | |
| BRAKE BOOSTER PUSH ROD ADJUSTMENT. BRAKE PEDAL FEEL CONDITION. *MJ | |
| Bulletin Number: 16412 | |
| SULPHUR SMELL FROM EXHAUST UNDER INVESTIGATION (QSF). *MJ | |
| Bulletin Number: 16770 | |
| SPEED CONTROL DEACTIVATION SWITCH ADJUSTMENT SERVICE PROCEDURE. *TT | |
| Bulletin Number: 17502 | |
| SLOW OR BINDING SIDE DOOR GLASS OPERATION. *TT | |
| Bulletin Number: 17757 | |
| INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 17810 | |
| TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN. *TT | |
| Bulletin Number: 17871 | |
| MULTIPLE DRIVEABILITY CONCERNS UNDER ACCELERATION CAUSED BY IGNITION COIL. *TT | |
| Bulletin Number: 18383 | |
| AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP. *TT | |
| Bulletin Number: 18426 | |
| AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE . *EH | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 MERCURY MOUNTAINEER | |
| Bulletin Number: 002310 | |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT | |
| Bulletin Number: 011002 | |
| SOME 4-DOOR VEHICLES BUILT 11/13/2000 THROUGH 4/2/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION. THIS MAY BE CAUSED BY COMTAMINATION ON THE COOLER TUBE B | |
| Bulletin Number: 011007 | |
| SOME VEHICLES BUILT 11/13/2000 THORUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL INDICATOR LAMP (TCIL) FLASHING WITH VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) IN SELF TEST. DTC PO713 IS THE CODE THAT IS | |
| Bulletin Number: 01102 | |
| A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION. THIS MAY BE CAUSED BY CONTAMINATION ON THE COOLER TUBE BETWEEN THE TUBE NUT AND FLARE, CONTAMINATION ON THE TUBE NUT THREADS OR IMPROPER INSTALLATION TORQUE. V | |
| Bulletin Number: 01107 | |
| SOME VEHICLES BUILT 11/13/2000 THROUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL INDICATOR LAMP (TCIL) FLASHING WITH VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) IN SELF TEST. DTC P0713 IS THE CODE THAT IS | |
| Bulletin Number: 01111 | |
| SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT 11/13/2000 THROUGH 5/21/2001 MAY EXHIBIT LIGHT THROTTLE SOFT OR LONG 2-3 UPSHIFTS BETWEEN 16-40 KM/H (10-25 MPH) OR HARSH 3-4 UPSHIFTS BETWEEN 32-56 KM/H (20-3 | |
| Bulletin Number: 011110 | |
| SOME VEHICLES EQUIPPED WITH A CLASS II HITCH MAY EXHIBIT INSUFFICIENT CLEARANCE INT HE RECEIVER TO ATTACH TUBULAR HITCH ACESSORIES TO THE VEHICLE. *TT | |
| Bulletin Number: 01115 | |
| FLUID LEAK IN THE CONVERTER HOUSING AREA ON VEHICLES BUILT 11/13/2000 THROUGH 4/27/2001. *TT | |
| Bulletin Number: 01126 | |
| SOME VEHICLES EQUIPPED WITH THE MANUAL A/C SYSTEM MAY EXHIBIT A CONTINUOUS CLICKING NOISE FROM THE BLEND DOOR ACTUATOR WHENTHE BLOWER SPEED IS SET AT THE #2 POSITION AND THE TEMPERATURE CONTROL KNOB IS SET BETWEEN THE 12:00 AND 2:00 POSITIO | |
| Bulletin Number: 01142 | |
| SOME VEHICLES, BUILT PRIOR TO 8/01/2001, MAY EXHIBIT A WHINE OR HOWL NOISE DURING COLD STARTS AT TEMPERATURES BELOW 4 DEGREES C (40 DEGREES F). *TT | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01203 | |
| EXHIBIT HARSH 1-2, 3-4 UPSHIFTS AT LIGHT TO MEDIUM THROTTLE ON SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT THROUGH 9/21/2001. *TT | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 01207 | |
| SOME VEHICLES PRODUCED BEFORE 9/6/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A TICK NOISE EMANATING FROM THE FRONT OR INTERMEDIATE SERVO COVER. *TT | |
| Bulletin Number: 01223 | |
| SOME VEHICLES BUILT PRIOR TO 11/11/2001 EQUIPPED WITH 5R55W TRANSMISSION AND 4.6L ENGINE, MAY EXHIBIT A BUZZING NOISE WHEN THE TORQUE CONVERTER IS ENGAGED. *TT | |
| Bulletin Number: 01245 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L ENGINE MAY EXHIBIT A CONDITION OF UNABLE TO ACCESS WITH THE SECURILOCK PASSIVE ANTI-THEFT SYSTEM (PATS). *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0162 | |
| VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT | |
| Bulletin Number: 0186 | |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT | |
| Bulletin Number: 01B77 | |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT | |
| Bulletin Number: 01T02 | |
| LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE. *MR | |
| Bulletin Number: 01T02 | |
| SPECIAL SERVICE INSTRUCTIONS FOR THE LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE. *TT | |
| Bulletin Number: 02101 | |
| SOME ALL-WHEEL DRIVE VEHICLES MAY EXHIBIT A GROWL NOISE AT SPEEDS OF 65-112 KM/H (40-70 MPH). *TT | |
| Bulletin Number: 0213 | |
| SOME ALL WHEEL DRIVE EQUIPPED VEHICLES MAY EXHIBIT A GROWL NOISE AT SPEEDS OF 65-112 KM/H (40-70 MPH). *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02171 | |
| PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS. *MJ | |
| Bulletin Number: 021710 | |
| ELECTRICAL-CENTRAL SECURITY MODULE (CSM) SERVICE TIPS. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02216 | |
| EXCESSIVE SULFUR SMELL FROM EXHAUST. *EH | |
| Bulletin Number: 0232 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 0262 | |
| SUBJECT REGARDING 5R55W AUTOMATIC TRANSMISSION HARSH UPSHIFTS DURING LIGHT TO MEDIUM THROTTLE CONCERNS. *TT | |
| Bulletin Number: 0276 | |
| INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 0281 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03106 | |
| THROTTLE CABLE ROUTING AND SPLASH SHIELD MODIFICATION WHEN REPLACING THROTTLE CABLE DURING NORMAL SERVICE. *TT | |
| Bulletin Number: 03126 | |
| LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED - SERVICE PROCEDURE. *TT | |
| Bulletin Number: 03136 | |
| NO CRANK CONDITION. SERVICE TIPS. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03147 | |
| SHUDDER DURING 4/5 UPSHIFT AND/OR 5/4 DOWNSHIFT ON VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03198 | |
| CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03254 | |
| 5R55W TRANSMISSION - NO 3RD GEAR OR SLIPPING 2-3 SHIFT - DIAGNOSTIC TROUBLE CODE P0733 AND P0745 - VEHICLES BUILT PRIOR TO 3/4/2002. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03263 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODE (DTC) C1235, C1236, C1237 ON VEHICLES WITH DIFFERENTIAL-MOUNTED RAR WHEEL SPEED SENSOR. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0357 | |
| FLUID LEAK FROM THE CONVERTER HOUSING AREA. *TT *JB | |
| Bulletin Number: 0365 | |
| INTERMITTENT FUEL GAUGE LEVEL DROPPING TO EMPTY WHEN FUEL LEVEL IS NOT ACTUALLY EMPTY. DIAGNOSTIC TROUBLE CODES B1201, B1202, B1204 MAY OR MAY NOT BE PRESENT. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04105 | |
| AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04181 | |
| CLEAR COAT PEEL OFF THE WHEEL OR CRACKS THAT LOOK LIKE SPIDER WEBS UNDER THE CLEAR COAT - 16 INCH WHEELS. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042115 | |
| FUEL GAUGE SLOW TO UPDATE AFTER REFUELING. *EH | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042212 | |
| GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 04259 | |
| REAR POWER WINDOW(S) INOPERATIVE. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 0485 | |
| LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED. SERVICE PROCEDURE. *TT | |
| Bulletin Number: 04B15 | |
| REAR AXLE DATE CODE INSPECTION AND SERVICE. VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER MIX OF REAR AXLE LUBRICANT AND FRICTION MODIFIER ADDITIVE. IF SO, THE CUSTOMER MAY EXPERIENCE NOISE AND VIBRATION WHILE DRIVING. *TT *MJ | |
| Bulletin Number: 050618 | |
| REAR AXLE NOISE REPAIR. *SC | |
| Bulletin Number: 051313 | |
| HARD START/NO START CONDITION DURING COLD AMBEINT TEMPERATURES AFTER SHORT HOT SOAK PERIOD-4.0L ENGINE. *SC | |
| Bulletin Number: 05136 | |
| BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP. *TT | |
| Bulletin Number: 051710 | |
| NOISE FROM REAR WHEEL HUB BEARINGS. *TT | |
| Bulletin Number: 05213 | |
| MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT | |
| Bulletin Number: 0537 | |
| DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE. *TT | |
| Bulletin Number: 05416 | |
| FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING. *TT | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 05618 | |
| REAR AXLE NOISE REPAIR. *TT | |
| Bulletin Number: 05N04 | |
| EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 14710 | |
| SUBJECT REGARDING EDSR BONUS POINTS. *TT | |
| Bulletin Number: 14723 | |
| SOME VEHICLES MAY EXHIBIT A TINNY RATTLE NOISE COMING FROM THE CENTER STEERING COLUMN AREA WHILE DRIVING OVER BUMPY ROADS. THIS MAY BE DUE TO A FREQUENCY BEING INDUCED INTO THE BRAKE SHIFT INTERLOCK (BSI) SWITCH PINTLE, CREATING AN AUDIBL | |
| Bulletin Number: 14726 | |
| INFORMATION ON THE INTAKE MANIFOLD VALLEY STUFFER BAG. *TT | |
| Bulletin Number: 14741 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT. *TT | |
| Bulletin Number: 14741 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT. *TT | |
| Bulletin Number: 14742 | |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH EGR SYSTEM RELATED DIAGNOSTIC TROUBLE CODES P0400, P0401, P0402, P1400, P1401, P1405, P1406, P1408, P1409. *TT | |
| Bulletin Number: 14745 | |
| INFORMATION ON OBTAINING ENGINEERING ASSISTANCE FOR ANTI-LOCK BRAKE SYSTEM. *TT | |
| Bulletin Number: 14759 | |
| INFORMATION REGARDING TRANSMISSION OIL LEVEL CHECKING GUIDELINES. *TT | |
| Bulletin Number: 14795 | |
| SOME VEHICLES MAY EXHIBIT A NOISY AND / OR LOOSE FRONT WHEEL BEARING. *TT | |
| Bulletin Number: 14804 | |
| INFORMATION ON FRONT WHEEL HUB ASSEMBLIES. *TT | |
| Bulletin Number: 14827 | |
| INFORMATION ON VEHICLES EQUIPPED WITH WITH 5R55W TRANSMISSION HAVING A (POWERTRAIN CONTROL MODULE) PCM ADAPTIVE LEARNING STRATEGY FEATURE THAT CONTROLS SHIFT FEEL AND TIMING. *TT | |
| Bulletin Number: 14866 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT | |
| Bulletin Number: 14868 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT | |
| Bulletin Number: 14872 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER (PTEC) WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 14874 | |
| SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION. THIS MAY BE DUE TO THE BRAKE SHIFT INTERLOCK SWITCH. *TT | |
| Bulletin Number: 14881 | |
| SOME VEHICLES EQUIPPED WITH 7 PASSENGER SEATING MAY EXHIBIT THE 2ND ROW 40 PERCENT SEAT BACK STAYING IN THE DOWN POSITION. THIS MAY BE DUE TO A RIVET INTERFERENCE AT THE FLOORPAN LATCHES. *TT | |
| Bulletin Number: 14890 | |
| SOME VEHICLES MAY EXHIBIT EXCESSIVE EFFORTS WHEN TRYING TO INSERT OR REMOVE THE KEY FROM THE IGNITION LOCK. *TT | |
| Bulletin Number: 14894 | |
| SOME VEHICLES MAY EXHIBIT A REPETITIVE THUMP / KNOCK NOISE FROM THE REAR WHICH IS PROPORTIONAL TO WHEEL SPEED WHEN BRAKE. THIS MAY BE CAUSED BY THE INITIAL FINISH / SPIRAL CUT OF THE REAR BREAK ROTOR(S). *TT | |
| Bulletin Number: 14896 | |
| SOME VEHICLES MAY EXHIBIT AN ERROR INDICATING THAT THERE IS NO COMMUNICATION OR RETURN DIAGNOSTIC TROUBLE CODES (DTC) THAT ARE NOT RELATED TO THE ANTI-LOCK BRAKE (ABS) SYSTEM WHEN RETRIEVING DTCS FROM OR ATTEMPTING TO VIEW PIDS IN THE ABS M | |
| Bulletin Number: 14900 | |
| SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM LIGHT ON WITH DIAGNOSTIC TROUBLE CODE C1230 AND / OR C1237 FROM THE ANTI-LOCK BRAKE SYSTEM. *TT | |
| Bulletin Number: 14901 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION IN WHICH THE REAR DOOR(S) WILL NOT UNLOCK VIA MANUAL OR POWER OPERATION. *TT | |
| Bulletin Number: 14903 | |
| INFORMATION REGARDING TRAILER WIRING - BRAKE CONTROLLER CONNECTOR LOCATION. *TT | |
| Bulletin Number: 14906 | |
| INFORMATION ON PERFORMING ANY PASSTIVE ANTI-THEFT (PATS) SYSTEM FUNCTIONS INCLUDING KEY REPLACEMENTS WITH WDS OR NGS. *TT | |
| Bulletin Number: 14923 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT | |
| Bulletin Number: 14933 | |
| SOME VEHICLES MAY EXHIBIT A YELLOW FOUR WHEEL ANTI-LOCK BRAKE (4WABS) LAMP ILLUMINATED AND A DIAGNOSTIC TROUBLE CODE (DTC) B1342 (ANTI-LOCK BRAKE CONTROL MODULE FAILURE) IN SELF TEST. *TT | |
| Bulletin Number: 14934 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT | |
| Bulletin Number: 14947 | |
| SOME VEHICLES MAY EXHIBIT A STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 14950 | |
| SOME ALL-WHEEL DRIVE VEHICLES MAY EXHIBIT A WHINE NOISE FROM THE FRONT DRIVELINE AT SPEEDS BETWEEN 40 AND 80 MILES PER HOUR. *TT | |
| Bulletin Number: 14966 | |
| SOME ALL-WHEEL DRIVE VEHICLES MAY EXHIBIT A WHINE NOISE FROM THE FRONT DRIVELINE AT SPEEDS BETWEEN 40 AND 80 MILES PER HOUR. *TT | |
| Bulletin Number: 14983 | |
| SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROM THE EXHAUST SYSTEM WHILE OEPRATING UNDER DRIVE MODES. *TT | |
| Bulletin Number: 15017 | |
| STIFF STEERING OR POOR STEERING WHEEL RETURNABILITY. *TT | |
| Bulletin Number: 15019 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT A WHINE NOISE THAT OCCURS IN 3RD GEAR ONLY. *TT | |
| Bulletin Number: 15030 | |
| SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION. *TT | |
| Bulletin Number: 15041 | |
| SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT A ROUGH IDLE CONDITION. *TT | |
| Bulletin Number: 15054 | |
| VEHICLES WITH 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION. *TT | |
| Bulletin Number: 15055 | |
| INFORMATION ON THE LOCATION OF THE HEATED SEAT SWITCH. *TT | |
| Bulletin Number: 15058 | |
| SOME VEHICLES EQUIPPED WITH A 5R55W AUTOMATIC TRANSMISSION MAY EXHIBIT A TICK NOISE WHILE AT IDLE IN PARK AND NEUTRAL. *TT | |
| Bulletin Number: 15069 | |
| VEHICLES EQUIPPED WITH THE 5R55W AUTOMATIC TRANSMISSION BUILT PRIOR TO 08/01/2001 MAY EXHIBIT A NEUTRAL OUT CONDITION WHEN COMING TO A STOP. *TT | |
| Bulletin Number: 15080 | |
| SOME VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT. *TT | |
| Bulletin Number: 15084 | |
| STEERING WHEEL SHUDDER DURING LOW-SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 15088 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT NO TRANSMISSION ENGAGEMENT INTO FORWARD AND / OR REVERSE GEAR. *TT | |
| Bulletin Number: 15090 | |
| SOME VEHICLES MAY DEVELOP YELLOW STAINS ON THE REAR LIFTGATE PAINT, USUALLY NOTICED ON WHITE COLORED VEHICLES. *TT | |
| Bulletin Number: 15091 | |
| SOME VEHICLES MAY EXHIBIT A SCRUNCH NOISE FROM THE UPPER STEERING COLUMN WHEN MAKING NEAR FULL LOCK TURNS. *TT | |
| Bulletin Number: 15093 | |
| EXHIBITING DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15103 | |
| SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGHT IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT | |
| Bulletin Number: 15104 | |
| SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGH IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT | |
| Bulletin Number: 15105 | |
| SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION. *TT | |
| Bulletin Number: 15107 | |
| SOME VEHICLES MAY REQUIRE EXCESSIVE EFFORT WHEN TRYING TO INSERT THE KEY INTO THE IGNITION LOCK CYLINDER. *TT | |
| Bulletin Number: 15191 | |
| INFORMATION REGARDING NEW COMPASS SETTING PROCEDURE, PDI MUST SET ALL. *YD | |
| Bulletin Number: 15209 | |
| SOME ALL-WHEEL DRIVE VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT A WHINE NOISE FROM THE FRONT DRIVELINE AT SPEEDS BETWEEN 40 - 80 MPH. *TT | |
| Bulletin Number: 15210 | |
| SOME VEHICLES EQUPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROMTHE EXHAUST SYSTEM WHILE OPERATING UNDER CERTAIN DRIVE MODES RELATED TO CALIBRATION. *TT | |
| Bulletin Number: 15215 | |
| SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457 STORED. *TT | |
| Bulletin Number: 15215 | |
| SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457. *TT | |
| Bulletin Number: 15242 | |
| SOME VEHICLES MAY EXHIBIT UNEVEN AIR DISCHARGE TEMPERATURES IN A/C COOLING MODES. *TT | |
| Bulletin Number: 15248 | |
| SOME OWNERS MAY NOTICE A KNOCKING NOISE FROM THE REAR OF THE VEHICLE WHEN THE BRAKES ARE APPLIED. *TT | |
| Bulletin Number: 15250 | |
| INFORMATION REGARDING MISDIAGNOSIS OF MAIN CONTROLS - INCORRECT PRESSURES. *TT | |
| Bulletin Number: 15251 | |
| SOME 4X4 VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT. *TT | |
| Bulletin Number: 15263 | |
| CONCERNS WITH A/C PERFORMANCE TEMP. DIFFERENCE SIDE-SIDE AT REGISTERS. *TT | |
| Bulletin Number: 15267 | |
| SOME VEHICLES WITH 5R5W MAY EXHIBIT A NO ENGAGEMENT CONDITION. ENGINEERING IS INVESTIGATING. *TT | |
| Bulletin Number: 15286 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER (PTEC) WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 15287 | |
| SOME VEHICLES MAY EXHIBIT A FLUTTER/TURBULENCE NOISE CONDITION (I.E., HELICOPTER NOISE) AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOWS ARE IN THE DOWN POSITION. *TT | |
| Bulletin Number: 15290 | |
| SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA. *TT | |
| Bulletin Number: 15329 | |
| SOME VEHICLES EQUIPPED WITH 3RD ROW SEATING MAY EXHIBIT A CONDITION WITH THE SEAT RELEASE LATCH STICKING/BINDING. *TT | |
| Bulletin Number: 15335 | |
| CONCERNS WITH SQUEAK AND RATTLE NOISS COMING FROM THE INSTRUMENT PANEL AND FROM THE SIDE DOOR WINDOWS. *TT | |
| Bulletin Number: 15383 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER WITH THE WDS/NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 15408 | |
| SOME VEHICLES EQUIPPED WITH DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MAY EXHIBIT INOPERATIVE REDUNDANT STEERING WHEEL CONTROLS (RSWC). *TT | |
| Bulletin Number: 15423 | |
| EXHIBITING ROUGH IDLE, OR ROUGH IDLE UPON INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT | |
| Bulletin Number: 15445 | |
| SOME VEHICLES MAY EXHIBIT A RATTLE NOISE WHEN CLOSING EITHER THE MIDGATE OR THE REAR LIFTGATE. *TT | |
| Bulletin Number: 15470 | |
| CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 15486 | |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL). *TT | |
| Bulletin Number: 15489 | |
| SOME VEHICLES EQUIPPED WITH 4.6L ENGINES MAY EXHIBIT A HIGH FREQUENCY WHINE NOISE (HAIR DRYER TYPE NOISE), THAT LASTS FOR 30-60 SECONDS AFTER COLD START. *TT | |
| Bulletin Number: 15495 | |
| SOME ALL WHEEL DRIVE VEHICLES MAY EXHIBIT A GROWL NOISE AT SPEEDS OF APPROXIMATELY 45 MPH AND ABOVE. *TT | |
| Bulletin Number: 15504 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15519 | |
| SOME VEHICLES MAY EXPERIENCED A STRONG SULPHUR ODOR DURING CERTAIN DRIVE MODES.*YD | |
| Bulletin Number: 15532 | |
| INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT | |
| Bulletin Number: 15540 | |
| INFORMATION REGARDING ENGINE WIND NOISE.*YH | |
| Bulletin Number: 15563 | |
| INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH | |
| Bulletin Number: 15575 | |
| SOME VEHICLES MAY EXHIBIT THE DRIVERS DOOR UNLOCKING AFTER IT HAS BEEN LOCKED. *TT | |
| Bulletin Number: 15580 | |
| SOME 4 DOOR VEHICLES MAY EXHIBIT A STEERING COLUMN RATTLE AT SPEEDS OF 10-20 MPH ON UNEVEN SURFACES. *TT | |
| Bulletin Number: 15605 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15646 | |
| CONCERNS WITH CLUNK NOISE FROM FRONT AXLE AREA. *TT | |
| Bulletin Number: 15647 | |
| SOME VEHICLES EQUIPPED WITH A V6 ENGINE MAY EXHIBIT A STEERING RATTLE NOISE WHICH MAY BE HEARD AND FELT IN THE STEERING WHEEL AND COLUMN. *TT | |
| Bulletin Number: 15683 | |
| SOME VEHICLES MAY EXHIBIT A NEED FOR HEADLAMP AIM ADJUST AFTER DRIVING ON ROUGH ROADS. *TT | |
| Bulletin Number: 15783 | |
| SOME VEHICLES MAY EXHIBIT EXCESSIVE SULPHUR SMEEL FROM THE EXHAUST UNDER CERTAIN DRIVE MODES. *TT | |
| Bulletin Number: 15804 | |
| SOME VEHICLES BUILT SINCE OCTOBER 1, 2001 MAY EXHIBIT A NO START CONDITION OR AN INTERMITTENT NO START CONDITION, AND / OR POSSIBLY NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 15829 | |
| SUBJECT REGARDING CIGAR LIGHTER REVISED INSTALLATION PROCEDURES. *TT | |
| Bulletin Number: 15840 | |
| SOME VEHICLES WITH THE 4.6L ENGINE AND ALL WHEEL DRIVE BUILT BETWEEN 02/25 AND 04/24, 2002 MAY EXHIBIT A SHUDDER ON THE 4-5 UPSHIFT AND / OR THE 5-4 DOWNSHIFT. *TT | |
| Bulletin Number: 15853 | |
| SUBJECT REGARDING INTERMITTENT ENGINE QUIT DURING TRANSMISSION ENGAGEMENTS OR PARKING MANEUVERS. *TT | |
| Bulletin Number: 15892 | |
| SUBJECT REGARDING REAR LIFTGATE APPLIQUE (TRIM PANEL) CRACKS. *TT | |
| Bulletin Number: 15899 | |
| SUBJECT REGARDING THEFT LIGHT RELOCATION. *TT | |
| Bulletin Number: 15906 | |
| INFORMATION ON POWER STEERING LEAK CONDITION. *TT | |
| Bulletin Number: 15910 | |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT | |
| Bulletin Number: 15912 | |
| SUBJECT REGARDING FAMILY OR REAR SEAT ENTERTAINMENT SYSTEM HANDLE CONCERNS. *TT | |
| Bulletin Number: 15938 | |
| INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT | |
| Bulletin Number: 15984 | |
| EXHIBITING SQUEAK / CREAK NOISES DURING FRONT SUSPENSION MOVEMENT. *TT | |
| Bulletin Number: 16029 | |
| SOME VEHICLES MAY EXHIBIT UNINTENDED SMART UNLOCK ACTIVATION WITHOUT KEY IN IGNITION. *TT | |
| Bulletin Number: 16090 | |
| SOME 4DR VEHICLES MAY EXHIBIT SEATING APPEARANCE OR RELATED ISSUES. *TT | |
| Bulletin Number: 16094 | |
| SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT | |
| Bulletin Number: 16159 | |
| SOME VEHICLES BUILT AFTER MARCH 2002 MAY NOT ALLOW PASSIVE ANTI-THEFT SYSTEM (PATS) SECURITY ACCESS WHEN PROGRAMMING SPARE KEYS OR REPLACING DEFECTIVE KEYS. *TT | |
| Bulletin Number: 16195 | |
| CONTACT ST LOUIS ASSEMBLY PLANT/ST LOUIS VICINITY ONLY. *MJ | |
| Bulletin Number: 16304 | |
| SUN VISOR RATTLE / DETROIT AREA DEALERS CONTACT REQUEST. *TT | |
| Bulletin Number: 16309 | |
| HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR. *TT | |
| Bulletin Number: 16427 | |
| LOW SPEED OR STATIONARY NOISE/VIBRATION AT LOWER STEERING SHAFT AREA WHEN TURNING. *MJ | |
| Bulletin Number: 16508 | |
| VIBRATION CONDITION. CONTACT REQUEST ST. LOUIS REGION. OASIS. *TT | |
| Bulletin Number: 16608 | |
| UNINTENDED DOOR UNLOCKS WITHOUT KEY IN IGNITION (QSF). *TT | |
| Bulletin Number: 16617 | |
| OPEN F2.20 5 AMP FUSE WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT | |
| Bulletin Number: 16618 | |
| ILLUMINATED AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE (DTC) B2292. *TT | |
| Bulletin Number: 16665 | |
| BLINKING/HALF ILLUMINATED SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AND/OR ANTI-LOCK BRAKE (ABS) WARNING INDICATORS AFTER COLD SOAK DURING AMBIENT TEMPERATURES COLDER THAN 30 DEGREES FAHRENHEIT. *TT | |
| Bulletin Number: 16688 | |
| BACK GLASS HINGE RATTLING/LOOSENESS, GLASS MISALIGNMENT AND/OR GLASS HARD-TO-CLOSE. *TT *JB | |
| Bulletin Number: 16703 | |
| BATTERY LIGHT ON OR AN ALTERNATOR THAT IS NOT CHARGING. *TT *JB | |
| Bulletin Number: 16706 | |
| SQUEAKING ACCELERATOR PEDAL WHILE DRIVING DURING COLD, HOT, DUSTY, AND DRY CONDITIONS. *TT *JB | |
| Bulletin Number: 16771 | |
| ROUGH / ROLLING IDLE AND HESITATION ON ACCELERATION AFTER A FIRST COLD STARTUP. *TT | |
| Bulletin Number: 16806 | |
| FLUID LEAKS FROM THE REAR HALFSHAFT SEAL. 2002-2003 EXPLORER/MOUNTAINEER/AVIATOR ADDED. *TT | |
| Bulletin Number: 16898 | |
| A WHINE NOISE ON TIP-IN AT SPEEDS OF 45 TO 65 MPH. THIS MAY BE DUE TO DRIVELINE STACK-UP TOLERANCE WITH THE DRIVESHAFT AND REAR AXLE. *TT | |
| Bulletin Number: 16918 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH CODES C1235 AND C1236 OR C1237. *TT | |
| Bulletin Number: 16926 | |
| STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS. *TT | |
| Bulletin Number: 16949 | |
| REAR AXLE VIBRATION/DRONE ABOVE 60 MPH. *TT | |
| Bulletin Number: 16967 | |
| CLUSTER LOCKING UP & VARIOUS ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF BEING INOPERATIVE. *TT | |
| Bulletin Number: 16968 | |
| DRIVEABILITY CONDITIONS DUE TO CALIBRATION VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE. IDLE AIR CONTROL (IAC) VALVE REPLACEMENT FOR THESE SYMPTOMS IS TYPICALLY NOT EFFECTIVE. *TT | |
| Bulletin Number: 17002 | |
| AN INTERMITTENT OR CONTINUOUS OPEN OF FUSE 1.15. *TT | |
| Bulletin Number: 17011 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC'S) P0171, P0172, P0174, OR P0175. *TT | |
| Bulletin Number: 17049 | |
| ROUGH IDLE / ENGINE SHAKE. *TT | |
| Bulletin Number: 17054 | |
| AXLE WHINE AT CRUISE OR DURING ACCELERATION/ DECELERATION. *TT | |
| Bulletin Number: 17069 | |
| ROUGH/ROLLING IDLE OR HESITATION AFTER FIRST STARTUP OR A ROUGH/ROLLING ENGINE SPEED WHEN RETURNING TO IDLE AFTER A SHORT TRIP. *TT | |
| Bulletin Number: 17107 | |
| DRIVELINE VIBRATION ON DRONE/BOOM AT HIGHWAY SPEEDS. *TT | |
| Bulletin Number: 17163 | |
| EXCESSIVE ENGINE COOLING FAN NOISE. *TT | |
| Bulletin Number: 17167 | |
| MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE. 2004 SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 17215 | |
| THE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C1235, C1236/C1237 STORED IN MEMORY. *TT | |
| Bulletin Number: 17216 | |
| BREAKAGE OF A LIFTGATE WINDOW HINGE. *TT | |
| Bulletin Number: 17217 | |
| AIR CONDITIONER HOOTING NOISE DURING LIGHT LOAD ACCELERATION AT LOW SPEEDS, FROM 1000-1300 RPM. *TT | |
| Bulletin Number: 17246 | |
| INSTRUMENT CLUSTER LOCKING UP AND ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF INOPERATIVE. *TT | |
| Bulletin Number: 17280 | |
| GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17375 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON AND HARD START/LONG CRANK. *TT | |
| Bulletin Number: 17494 | |
| DISTANCE TO EMPTY NOT DISPLAYED. *TT | |
| Bulletin Number: 17544 | |
| GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ | |
| Bulletin Number: 17555 | |
| CERTIFIED REAR AXLE AVAILABLE. *MJ | |
| Bulletin Number: 17560 | |
| REAR AXLE NOISE. ALSO INCLUDES LINCOLN AVIATOR 2002. *MJ | |
| Bulletin Number: 17640 | |
| POOR FIT BETWEEN DRIVER AIR BAG AND STEERING WHEEL. *TT | |
| Bulletin Number: 17641 | |
| REAR 3.55 AXLE NOISE. CERTIFIED REAR AXLE OR IMPROVED GEAR SET AVAILABLE. *TT | |
| Bulletin Number: 17717 | |
| REAR AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. *TT | |
| Bulletin Number: 17729 | |
| MESSAGE CENTER DISPLAYS COMPUTING FUEL INSTEAD OF DISTANCE TO EMPTY. *TT | |
| Bulletin Number: 17736 | |
| REAR AXLE NOISE. *TT | |
| Bulletin Number: 17905 | |
| MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT | |
| Bulletin Number: 18121 | |
| FUEL GAUGE SLOW TO UPDATE. *TT | |
| Bulletin Number: 18123 | |
| UPDATED REAR HALFSHAFT REMOVAL PROCEDURE. *TT | |
| Bulletin Number: 18171 | |
| NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C). *TT | |
| Bulletin Number: 18215 | |
| BROKEN REAR CARGO STORAGE DOOR LIFT HANDLE. VARIOUS MODELS INCLUDING 2005 EXPLORER/MOUNTAINEER. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18221 | |
| REAR AXLE NOISE. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18224 | |
| RUNS ROUGH OR MISFIRE - DIAGNOSTIC TROUBLE CODES P0300-P0308 OR P0316. *TT | |
| Bulletin Number: 18381 | |
| OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT | |
| Bulletin Number: 18572 | |
| NO START/HARD START N HOT SOAK RESTART. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: 19091 | |
| LOW OIL PRESSURE INDICATION/WARNING, A/C COMPRESSOR INOPERATIVE AND/OR NO CRANK CONDITION ON 4.6L EQUIPPED VEHICLES. *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: TSB-08-19-3 | |
| FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 MERCURY SABLE | |
| Bulletin Number: 0109-01 | |
| 2002 TAURUS/SABLE HEATER HOSE CLAMPS UPGRADE PRIOR TO SALE. *NLM | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 01T05 | |
| ON SOME VEHICLES, THE HEATER HOSE CLAMP MAY BE IMPROPERLY POSITIONED ONTHE HEATER HOSES LEADING TO AND FROM THE HEATER CORE. *TT | |
| Bulletin Number: 02111 | |
| FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02175 | |
| RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 02223 | |
| DRIVEABILITY-MALFUNCTION INDICATOR LAMP (MIL) WITH P0316 WHEN USING WINTER BLEND REFORMULATED FUELS AT TEMPERATURES ABOVE 50 DEGREES F (10 DEGREES C) DURING WINTER MONTHS-ROUGH OR ROLLING IDLE AFTER HOT SOAK RESTART P0191. TRANSAXLE-AX4S-1 | |
| Bulletin Number: 02236 | |
| ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0284 | |
| VEHICLES BUILT AFTER 4/8/2002 WILL NO LONGER BE EQUIPPED WITH THE FUEL PRESSURE RELIEF VALVE (SHRADER VALVE). *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03111 | |
| ENGINE COOLING FAN INDUCED BODY BOOM, ROUGH ENGINE IDLE SENSATION OR UNUSUAL ENGINE NOISE AT IDLE WHEN THE ENGINE COOLING FAN IS IN THE HIGH SPEED MODE. *TT | |
| Bulletin Number: 03123 | |
| TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031506 | |
| WATER IN THE BLOWER CASE OR ON THE PASSENGER SIDE FLOOR, AN INOPERATIVE CLIMATE CONTROL BLOWER MOTOR, A MOTOR THAT OPERATES ON HIGH SPEED ONLY, AND/OR A BLOWER MOTOR RESISTOR FAILURE. VEHICLES BUILT 5/1/2001 TO 12/15/2003. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 0325 | |
| GRUNTING NOISE FROM FRONT POWER WINDOW AFTER GLASS IS POWERED TO THE FULL-UP POSITION. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 0415 | |
| LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04208 | |
| CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04223 | |
| GRUNTING NOISE FROM FRONT POWER WINDOW GLASS IS POWERED TO THE FULL UP POSITION. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 042514 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0316 OR P030X - NO CRANK BATTERY DISCHARGED. *TT | |
| Bulletin Number: 05145 | |
| ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE. *SC | |
| Bulletin Number: 052212 | |
| BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT | |
| Bulletin Number: 05224 | |
| POWER LOCK CONCERNS - SERVICE TIP. *TT | |
| Bulletin Number: 05227 | |
| POWER WINDOW CONCERNS - SERVICE TIP. *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 15189 | |
| INFORMATION REGARDING WORKSHOP MANUAL UPDATE 2002 TAURUS AND SABLE P/S PUMP 3.0L 2V. *YD | |
| Bulletin Number: 15239 | |
| INFORMATION ON PRE DELIVERY TEMPORARY FAST IDLE. *TT | |
| Bulletin Number: 15280 | |
| SOME VEHICLESMAY EXHIBIT AN INTERMITTENT STICKING/BINDING IGNITION KEY LOCK CYLINDER AT OR NEAR THE START POSITION. *JG | |
| Bulletin Number: 15370 | |
| SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT | |
| Bulletin Number: 15392 | |
| SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT | |
| Bulletin Number: 15482 | |
| SOME VEHICLES EQUIPPED WITH A DURATEC ENGINE MAY EXPERIENCE ENGINE DAMAGE AS A RESULT OF MICROSCOPIC INTERNAL CRACKS IN A BATCH OF INTAKE VALVES. *TT | |
| Bulletin Number: 15680 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 2V ENGINE MAY EHXIBIT A RUNS ROUGH, CHECK ENGINE LIGHT AND / OR DIAGNOSTIC TROUBLE CODE P0316 AFTER HOT SOAK RESTART. *TT | |
| Bulletin Number: 15724 | |
| CONCERNS WITH FUEL GAUGE NOT READING FULL AFTER FILLING FUEL TANK. *TT | |
| Bulletin Number: 15745 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 2V ENGINE MAY EXHIBIT A RUNS ROUGH, CHECK ENGINE LIGHT, AND / OR DIAGNOSTIC TROUBLE CODE P0316 AFTER A HOT SOAK RESTART. *TT | |
| Bulletin Number: 15820 | |
| SOME VEHICLES EQUIPPED WITH AN AX4N/4F50N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT | |
| Bulletin Number: 15828 | |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT | |
| Bulletin Number: 15873 | |
| SUBJECT REGARDING A WATER LEAK CONDITION AT THE COWL AREA OF THE VEHICLE. *TT | |
| Bulletin Number: 15915 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 2V ENGINE MAY EXHIBIT A ROUGH RUN CONDITION AND DIAGNOSTIC TROUBLE CODE P0316 AFTER A HOT RESTART. *TT | |
| Bulletin Number: 16035 | |
| SOME VEHICLES MAY EXHIBIT A ROUGH ENGINE IDLE, ENGINE IDLE ROUGHNESS OR IDLE RPM DIP WITH THE AIR CONDITIONER ON, A DIAGNOSTIC TROUBLE CODE P0191 OR 1-2 UPSHIFT. *TT | |
| Bulletin Number: 16057 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 4V ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATION WITH A DIAGNOSTIC TROUBLE CODE P0191 (FUEL RAIL PRESSURE SENSOR CIRCUIT PERFORMANCE) IN MEMORY. *TT | |
| Bulletin Number: 16094 | |
| SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT | |
| Bulletin Number: 16190 | |
| LACK OF A/C COOLING. *MJ | |
| Bulletin Number: 16315 | |
| HEADLINER GRAB HANDLES LOOSEN. *TT | |
| Bulletin Number: 16613 | |
| VEHICLES WITH VERY LOW ODOMETER MILES, MAY EXHIBIT A HIGHER THAN NORMAL TEMPORARY START-UP FAST IDLE (1600-2500 RPM THAT DECREASES SLOWLY). NO SERVICE NECESSARY. *TT | |
| Bulletin Number: 16678 | |
| AX4S TRANSAXLE MAY EXHIBIT NO REVERSE ENGAGEMENT CONDITION. *TT *JB | |
| Bulletin Number: 16679 | |
| NEW PUSH TYPE FUEL CLIP AND CONNECTOR REMOVAL INSTRUCTIONS. *TT *JB | |
| Bulletin Number: 16710 | |
| RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT *JB | |
| Bulletin Number: 16982 | |
| CLUNKING/POPPING NOISE FROM THE PASSENGER SIDE OF THE ENGINE COMPARTMENT UPON ACCELERATION AND/OR DECELERATION. *TT | |
| Bulletin Number: 17094 | |
| RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT | |
| Bulletin Number: 17224 | |
| INTERMITTENT ROLLING IDLE ON VEHICLES EQUIPPED WITH A 3.0L 2-VALVE ENGINE. *TT | |
| Bulletin Number: 17225 | |
| STEERING COLUMN LOCK DISCONTINUED. *TT | |
| Bulletin Number: 17234 | |
| ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE. *TT | |
| Bulletin Number: 17281 | |
| SURGE AT CRUISE. *TT | |
| Bulletin Number: 17355 | |
| FUEL GAUGE WHICH DOES NOT READ COMPLETELY FULL WHEN THE FUEL TANK IS FILLED. *TT | |
| Bulletin Number: 17358 | |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT | |
| Bulletin Number: 17416 | |
| FUEL GAUGE DOES NOT READ FULL. *MJ | |
| Bulletin Number: 17434 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH CONTINUOUS MEMORY DIAGNOSTIC TROUBLE CODES (DTC'S) P0172/P0175 (SYSTEM TOO RICH). *TT | |
| Bulletin Number: 17503 | |
| SURGE AT A STEADY SPEED BETWEEN 35 AND 45 MPH WITH NO OTHER DRIVEABILITY CONCERNS. *TT | |
| Bulletin Number: 17564 | |
| FUEL GAUGE DOES NOT READ FULL AFTER FILLING TANK. *MJ | |
| Bulletin Number: 17703 | |
| TICKING NOISE FROM LEFT CYLINDER HEAD WITH WARM ENGINE. *TT | |
| Bulletin Number: 17960 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171/P0174, P1131/P1151, AND/OR P2195/P2197 IN CONTINUOUS MEMORY. *TT | |
| Bulletin Number: 18411 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195. *TT | |
| Bulletin Number: 18471 | |
| RKE INOPERATIVE. *EH | |
| Bulletin Number: 18614 | |
| SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: CSP-13B04 | |
| FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPEED CONTROL CABLE IS SUSCEPTIBLE TO DAMAGE AND CAN DISCONNECT DURING HOOD MAINTENANCE AND ALSO INTERFERE WITH FULL THROTTLE RETURN TO IDLE AFTER RELEASING ACCELERATOR PEDAL. MODELS 20 | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 MERCURY TRACER | |
| Bulletin Number: 04V09 | |
| TRW VEHICLE SAFETY SYSTEMS, INC. IS RECALLING CERTAIN SERVICE REPLACEMENT SEATBELT RETRACTORS (DRIVER'S SIDE FRONT RETRACTOR IN GRAY) MANUFACTURED IN DECEMBER 2002 AND SOLD AS A SERVICE REPLACEMENT PART BETWEEN DECEMBER 2002 AND JULY 2004. | |
| 2002 MERCURY VILLAGER | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01188 | |
| POWER DOOR LOCKS, SELF ACTIVATING OR CYCLING.*JB | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 0243 | |
| SOME VEHICLES BUILT FROM 9/26/1998 THROUGH 9/5/2001 MAY EXHIBIT POWER DOOR LOCKS THAT SELF-ACTIVE OR CYCLE ON. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03226 | |
| UPDATE WIRING HARNESS WHEN REPLACING FUEL INJECTOR. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 15110 | |
| INFORMATION REGARDING REAR ENTERTAINMENT SYSTEM LOCK DOWN SCREWS. *SLC | |
| Bulletin Number: 15229 | |
| SOME VEHICLES MAY EXHIBIT POOR AND / OR NO A/C PERFORMANCE. *TT | |
| Bulletin Number: 15351 | |
| SOME VEHICLES EQUIPPED WITH 15 INCH STEEL WHEELS AND GENERAL TIRES MAY EXHIBIT A VIBRATION ABOVE 45 MILES PER HOUR (MPH) FELT IN THE STEERING WHEEL, SEAT, OR FLOOR. *TT | |
| Bulletin Number: 15556 | |
| INFORMATION REGARDING FLIP OUT WINDOW LATCH ADJUSTMENT. *YH | |
| Bulletin Number: 15586 | |
| SOME VEHICLES MAY EXHIBIT INTERIOR LAMPS THAT COME ON WHILE DRIVING. *TT | |
| Bulletin Number: 15621 | |
| SOME VEHICLES WITH THE REAR SEAT ENTERTAINMENT SYSTEM MAY EXHIBIT AN INOPERATIVE CONDITION. *TT | |
| Bulletin Number: 15713 | |
| INFORMATION PERTAINING TO LIFTGATE CYLINDER OPERATION. *TT | |
| Bulletin Number: 15833 | |
| SUBJECT REGARDING REMOTE ENTRY TRANSMITTER PROGRAMMING PROCEDURE. *TT | |
| Bulletin Number: 15971 | |
| SOME VEHICLES MAY EXHIBIT STATIC OR IGNITION NOISE THROUGH THE RADIO ON THE AM BAND. *TT | |
Recalls for 2002 Mercury
| 2002 MERCURY COUGAR | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/25/1999 - 11/30/2001 |
| Potential Units Affected: | 88600 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE. Consequence:THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH. Action:THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 MERCURY MARINER | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/31/2001 - 09/01/2009 |
| Potential Units Affected: | 57 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning. Consequence:If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders. Action:Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28. | |
| 2002 MERCURY MARINER | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/31/2001 - 09/01/2009 |
| Potential Units Affected: | 57 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning. Consequence:If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders. Action:Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28. | |
| 2002 MERCURY MOUNTAINEER | |
|---|---|
| NHTSA Campaign ID: | TIRES:SIDEWALL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 08/14/2000 - 04/27/2001 |
| Potential Units Affected: | 52000 |
Defect Description:VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY. Consequence:OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 MERCURY MOUNTAINEER | |
|---|---|
| NHTSA Campaign ID: | VISIBILITY:GLASS, SIDE/REAR |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 02/05/2001 - 03/30/2001 |
| Potential Units Affected: | 50224 |
Defect Description:THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT. Consequence:ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED. Action:FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED. | |
| 2002 MERCURY MOUNTAINEER | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 03/15/1996 - 08/30/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 MERCURY SABLE | |
|---|---|
| NHTSA Campaign ID: | VISIBILITY:WINDSHIELD |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 10/29/2001 - 04/27/2002 |
| Potential Units Affected: | 67894 |
Defect Description:CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." THE WINDSHIELDS MAY POTENTIALLY EXHIBIT INCREASED WIND NOISE, WATER LEAKAGE, AND SQUEAKS AND RATTLES. Consequence:POTENTIAL LOSS OF WINDSHIELD RETENTION MAY ALSO REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH. Action:DEALERS WILL REPLACE THESE WINDSHIELDS. OWNER NOTIFICATION BEGAN ON MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD/MERCURY AT 1-800-392-3673. | |
| 2002 MERCURY SABLE | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/03/1999 - 09/14/2001 |
| Potential Units Affected: | 369614 |
Defect Description:CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM. Consequence:THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION. Action:OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. | |
| 2002 MERCURY SABLE | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/03/1999 - 03/31/2003 |
| Potential Units Affected: | 938789 |
Defect Description:CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH. Consequence:IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE. Action:DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
