Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES FITTED WITH SPEED CONTROL DEVICES AT GULF STATES TOYOTA'S VEHICLE PROCESSING CENTER OR INSTALLED BY CERTAIN TOYOTA DEALERS IN GULF STATES' REGION (ARKANSAS, LOUISIANA, MISSISSIPPI, OKLAHOMA, AND TEXAS). THE E-CLIP WHICH HOLDS THE SPEED CONTROL ASSEMBLY TO THE ACCELERATOR LINKAGE COULD BREAK. IF THE E-CLIP FAILS, THE SPEED CONTROL ATTACHMENT COULD COME OFF, CAUSING THE SPEED CONTROL TO STOP WORKING.

Consequence:

THE LOOSE ATTACHMENT COULD CAUSE THE ACCELERATOR TO STICK, PREVENTING NORMAL STOPPING AND HANDLING OF THE VEHICLE.

Action:

GULF STATES DEALERS WILL REPLACE THE E-CLIP WITH A COTTER PIN.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES FITTED WITH SPEED CONTROL DEVICES AT GULF STATES TOYOTA'S VEHICLE PROCESSING CENTER OR INSTALLED BY CERTAIN TOYOTA DEALERS IN GULF STATES' REGION (ARKANSAS, LOUISIANA, MISSISSIPPI, OKLAHOMA, AND TEXAS). THE E-CLIP WHICH HOLDS THE SPEED CONTROL ASSEMBLY TO THE ACCELERATOR LINKAGE COULD BREAK. IF THE E-CLIP FAILS, THE SPEED CONTROL ATTACHMENT COULD COME OFF, CAUSING THE SPEED CONTROL TO STOP WORKING.

Consequence:

THE LOOSE ATTACHMENT COULD CAUSE THE ACCELERATOR TO STICK, PREVENTING NORMAL STOPPING AND HANDLING OF THE VEHICLE.

Action:

GULF STATES DEALERS WILL REPLACE THE E-CLIP WITH A COTTER PIN.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES FITTED WITH SPEED CONTROL DEVICES AT GULF STATES TOYOTA'S VEHICLE PROCESSING CENTER OR INSTALLED BY CERTAIN TOYOTA DEALERS IN GULF STATES' REGION (ARKANSAS, LOUISIANA, MISSISSIPPI, OKLAHOMA, AND TEXAS). THE E-CLIP WHICH HOLDS THE SPEED CONTROL ASSEMBLY TO THE ACCELERATOR LINKAGE COULD BREAK. IF THE E-CLIP FAILS, THE SPEED CONTROL ATTACHMENT COULD COME OFF, CAUSING THE SPEED CONTROL TO STOP WORKING.

Consequence:

THE LOOSE ATTACHMENT COULD CAUSE THE ACCELERATOR TO STICK, PREVENTING NORMAL STOPPING AND HANDLING OF THE VEHICLE.

Action:

GULF STATES DEALERS WILL REPLACE THE E-CLIP WITH A COTTER PIN.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES FITTED WITH SPEED CONTROL DEVICES AT GULF STATES TOYOTA'S VEHICLE PROCESSING CENTER OR INSTALLED BY CERTAIN TOYOTA DEALERS IN GULF STATES' REGION (ARKANSAS, LOUISIANA, MISSISSIPPI, OKLAHOMA, AND TEXAS). THE E-CLIP WHICH HOLDS THE SPEED CONTROL ASSEMBLY TO THE ACCELERATOR LINKAGE COULD BREAK. IF THE E-CLIP FAILS, THE SPEED CONTROL ATTACHMENT COULD COME OFF, CAUSING THE SPEED CONTROL TO STOP WORKING.

Consequence:

THE LOOSE ATTACHMENT COULD CAUSE THE ACCELERATOR TO STICK, PREVENTING NORMAL STOPPING AND HANDLING OF THE VEHICLE.

Action:

GULF STATES DEALERS WILL REPLACE THE E-CLIP WITH A COTTER PIN.

Defect Description:

VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH A TEKONSHA TRAILER HITCH WIRING HARNESS AND CONVERTER AND DISTRIBUTED BY GULF STATES TOYOTA (TEXAS, OKLAHOMA, LOUISIANA, ARKANSAS, AND MISSISSIPPI). AN ELECTRICAL SHORT CIRCUIT CAN OCCUR IF WATER ENTERS THE CONVERTER HOUSING.

Consequence:

THIS SHORT CIRCUIT COULD CAUSE A FAILURE OF THE CONVERTER, AND IF A TRAILER IS BEING TOWED AT THE TIME, CAN ALSO CAUSE INOPERATIVE TRAILER LIGHTS.

Action:

THIS RECALL HAS BEEN SUPERSEDED BY RECALL NO. 02V-050.

Defect Description:

CERTAIN PICKUP TRUCKS EQUIPPED WITH A TEKONSHA TRAILER HITCH WIRING HARNESS AND CONVERTER AND DISTRIBUTED BY GULF STATES TOYOTA (TEXAS, OKLAHOMA, LOUISIANA, ARKANSAS, AND MISSISSIPPI). THE CIRCUITRY USED IN THE CONVERTER, WHICH IS INADEQUATE TO MANAGE PROPERLY VEHICLE AND/OR TRAILER-SIDE VOLTAGE SPIKES. IF THE CONVERTER IS EXPOSED TO A VOLTAGE SPIKE, IT COULD CAUSE AN ELECTRICAL SHORT OR OPEN CIRCUIT WITHIN THE CONVERTER.

Consequence:

THIS SHORT CIRCUIT COULD CAUSE A FAILURE OF THE CONVERTER, AND IF A TRAILER IS BEING TOWED AT THE TIME, CAN ALSO CAUSE INOPERATIVE TRAILER LIGHTS.

Action:

DEALERS WILL REPLACE THE WIRE HARNESS AND CONVERTER. OWNER NOTIFICATION BEGAN APRIL 22, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GULF STATES TOYOTA AT 1-800-444-1074.

Defect Description:

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2000-2004 AVALON VEHICLES. DUE TO IMPROPER CASTING OF THE STEERING LOCK BAR, THERE IS A POSSIBILITY THAT A MINUTE CRACK MAY DEVELOP ON THE SURFACE OF THE LOCK BAR. SUCH A CRACK MAY EXPAND OVER A LONG PERIOD OF REPEATED LOCK AND UNLOCK OPERATIONS, AND EVENTUALLY THE LOCK BAR COULD BREAK.

Consequence:

SHOULD THE STEERING LOCK BAR BREAK, THE STEERING WHEEL WOULD LOCK AND THE DRIVER WOULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE STEERING INTERLOCK DEVICE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 7, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO IMPROPER HEAT TREATMENT, THE REAR AXLE MAY NOT HAVE ADEQUATE STRENGTH IN SOME AREAS.

Consequence:

AFTER EXTENDED USE OF THE VEHICLE, THE REAR AXLE SHAFTS COULD FAIL OR BREAK.

Action:

DEALERS WILL INSPECT AND REPLACE THE REAR AXLE HUB ASSEMBLIES.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL AND V6 ENGINES, AND BUILT AT ONE OF TWO LINES AT THE KENTUCKY PLANT. THE ACCELERATOR CABLE HOUSING COULD BE DEFORMED AT THE CRUISE CONTROL ACTUATOR-TO-THROTTLE BODY CONNECTION. THE ACCELERATOR INNER-CABLE COULD WEAR AWAY AND EVENTUALLY BREAK.

Consequence:

THIS COULD ALLOW THE THROTTLE TO RETURN TO IDLE OR REMAIN IN ITS MOST RECENT POSITION REGARDLESS OF ACCELERATOR PEDAL OPERATION, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE ACCELERATOR CABLE. OWNER NOTIFICATION BEGAN FEBRUARY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO IMPROPER HEAT TREATMENT, THE REAR AXLE MAY NOT HAVE ADEQUATE STRENGTH IN SOME AREAS.

Consequence:

AFTER EXTENDED USE OF THE VEHICLE, THE REAR AXLE SHAFTS COULD FAIL OR BREAK.

Action:

DEALERS WILL INSPECT AND REPLACE THE REAR AXLE HUB ASSEMBLIES.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO IMPROPER HEAT TREATMENT, THE REAR AXLE MAY NOT HAVE ADEQUATE STRENGTH IN SOME AREAS.

Consequence:

AFTER EXTENDED USE OF THE VEHICLE, THE REAR AXLE SHAFTS COULD FAIL OR BREAK.

Action:

DEALERS WILL INSPECT AND REPLACE THE REAR AXLE HUB ASSEMBLIES.

Defect Description:

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE LUMINOUS INTENSITY OF THE DAYTIME RUNNING LAMP (DRL) WILL BE MODIFIED TO MEET THE STANDARD REQUIREMENTS.

Consequence:

Action:

DEALERS WILL INSTALL A RESISTOR, WHICH WILL DECREASE THE LUMINOUS INTENSITY OF THE DRL. THE RECALL BEGAN ON MARCH 16, 2005. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Defect Description:

CERTAIN PASSENGER VEHICLES HAVE THE POSSIBILITY THAT THE RECESS RETAINS A RUBBER SEAL RING, WHICH IS LOCATED AT THE END OF THE CYLINDER BODY, AND MAY BE CORRODED DUE TO AN IMPROPER WASHING PROCESS.

Consequence:

IN THIS CONDITION, BRAKE FLUID MAY LEAK FROM THE SEAL, OR A SMALL AMOUNT OF AIR MAY ENTER THE MASTER CYLINDER, WHICH COULD LEAD TO AN INCREASE OF VEHICLE STOPPING DISTANCE.

Action:

DEALERS WILL INSPECT THE BRAKE MASTER CYLINDER AND, IF NECESSARY, REPLACE THE BRAKE MASTER CYLINDER AND BOOSTER. THE RECALL BEGAN ON NOVEMBER 29, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-888-270-9371.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. CONDENSED MOISTURE FROM THE POSITIVE CRANKCASE VENTILATION (PCV) PORT COULD SEEP TOWARD THE BRAKE VACUUM PORT INSIDE THE INTAKE MANIFOLD AND START TO FREEZE.

Consequence:

VACUUM ASSIST TO THE BRAKES WOULD BE DECREASED AND INCREASED PEDAL PRESSURE WOULD BE REQUIRED, INCREASING THE VEHICLE STOPPING DISTANCE.

Action:

DEALERS WILL REPAIR THE VACUUM PORT. ALSO, OWNERS OF THE SUBJECT VEHICLES IN STATES OTHER THAN THE RECALL STATES WILL BE NOTIFIED OF THE RECALL. IF THE ECHO OWNER BELIEVES THAT THERE IS A POSSIBILITY THAT THE VEHICLE WILL BE OPERATED IN THESE STATES DURING THE WINTER OR IN CONDITIONS DESCRIBED, THE VEHICLE SHOULD BE SERVICED FOR THIS RECALL.

Defect Description:

CERTAIN PASSENGER VEHICLES HAVE THE POSSIBILITY THAT THE RECESS RETAINS A RUBBER SEAL RING, WHICH IS LOCATED AT THE END OF THE CYLINDER BODY, AND MAY BE CORRODED DUE TO AN IMPROPER WASHING PROCESS.

Consequence:

IN THIS CONDITION, BRAKE FLUID MAY LEAK FROM THE SEAL, OR A SMALL AMOUNT OF AIR MAY ENTER THE MASTER CYLINDER, WHICH COULD LEAD TO AN INCREASE OF VEHICLE STOPPING DISTANCE.

Action:

DEALERS WILL INSPECT THE BRAKE MASTER CYLINDER AND, IF NECESSARY, REPLACE THE BRAKE MASTER CYLINDER AND BOOSTER. THE RECALL BEGAN ON NOVEMBER 29, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-888-270-9371.

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION. DUE TO A UNIQUE COMBINATION OF CONDITIONS WHICH CONSIST OF COLD AMBIENT TEMPERATURES, LOAD APPLIED FROM AIR CONDITIONER AND OTHER ELECTRICAL DEVICES, AND IMMEDIATELY AFTER STARTING THE ENGINE, THERE IS A POSSIBILITY THAT THE VACUUM IN THE INTAKE MANIFOLD COULD BE INSUFFICIENT FOR THE BRAKE BOOSTER.

Consequence:

WHEN THE BRAKE IS APPLIED UNDER THIS COMBINATION OF CONDITIONS, VACUUM ASSIST TO THE BRAKES WOULD DECREASE, AND THE INCREASED PEDAL PRESSURE REQUIRED COULD LEAD TO AN INCREASE IN VEHICLE STOPPING DISTANCE.

Action:

DEALERS WILL REPLACE THE BRAKE BOOSTER AND FRONT BRAKE PADS. OWNER NOTIFICATION BEGAN OCTOBER 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Defect Description:

VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. IF THE SUBJECT VEHICLES ARE REPEATEDLY PARKED BY PLACING THE SHIFT LEVER INTO THE "P" POSITION WITHOUT APPLYING THE PARKING BRAKE, THE PARKING LOCK ROD, A COMPONENT OF THE TRANSMISSION PARKING LOCK SYSTEM, COULD BREAK.

Consequence:

THIS CONDITION CAN RENDER THE SYSTEM INOPERATIVE, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE PARKING LOCK ROD.

Defect Description:

VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. THE FRONT DISC BRAKE ROTOR, WHEN EQUIPPED WITH STEEL WHEELS, CAN DEVELOP STRESS FRACTURES IF THE LUG NUTS ARE TIGHTENED WITH EXCESSIVE TORQUE.

Consequence:

THE DISC ROTOR COULD BREAK (WHERE IT MOUNTS TO THE WHEEL), RESULTING IN A LOSS OF BRAKING ACTION ON THAT WHEEL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE DISC BRAKE ROTORS. IF THE VEHICLE IS EQUIPPED WITH STEEL WHEELS, TOYOTA WILL REPLACE THE FRONT DISC BRAKE ROTORS AND STEEL WHEELS WITH NEW DISC BRAKE ROTORS AND NEW ALUMINUM WHEELS. IN ADDITION A CAUTION LABEL THAT READS, "USE NEW GENUINE TOYOTA ALUMINUM WHEELS." WILL BE AFFIXED. VEHICLES ALREADY EQUIPPED WITH ALUMINUM WHEELS WILL ONLY REQUIRE CAUTION LABEL INSTALLATION.

Defect Description:

TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.

Consequence:

THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Action:

TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect Description:

TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. EXCESSIVE CORROSION OF THE REAR CROSS MEMBER MAY CAUSE THE SEPARATION OF THE SPARE TIRE STOWED UNDER THE TRUCK BED WHICH WOULD PRESENT A ROAD HAZARD THAT COULD CAUSE A CRASH. ALSO, CORROSION OF THE REAR CROSS MEMBER COULD AFFECT THE REAR BRAKE LINES AND THE PROPORTIONING VALVE RESULTING IN DIMINISHED BRAKING CAPABILITY.

Consequence:

SEPARATION OF THE SPARE TIRE AND DIMINISHED BRAKE CAPACITY COULD INCREASE THE RISK OF A CRASH.

Action:

TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND RELATED COMPONENTS, INCLUDING THE BRAKE LINES, AND REPLACE THEM IF NECESSARY. IF THE CROSS MEMBER DOES NOT NEED TO BE REPLACED, IT WILL BE SPRAYED WITH A CORROSION PROTECTION COMPOUND. THESE SERVICES WILL BE PERFORMED FREE OF CHARGE, HOWEVER MULTIPLE VISITS TO THE DEALER MAY BE REQUIRED. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 30, 2010. OWNER MAY CONTACT TOYOTA AT 1-800-331-4331.

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS. THE TAIL LIGHT SOCKET MAY HAVE BEEN IMPROPERLY MOLDED, RESULTING IN THE LOCKING TAB HAVING INSUFFICIENT FORCE TO RETAIN THE BULB.

Consequence:

IF THE BULB FALLS OUT OF THE SOCKET, THE BRAKE OR TAIL LAMP FUNCTION CANNOT OCCUR.

Action:

DEALERS WILL REPLACE THE TAIL LAMP SOCKETS.

Defect Description:

ON CERTAIN 4X2 VEHICLES EQUIPPED WITH AN ALLOY WHEEL TIRE UPGRADE (OPTIONS WM4, WM8, ZL1-ZL4, DH4, OR DH5) INSTALLED BY THE PROCESSING CENTERS IN JACKSONVILLE, FLORIDA OR COMMERCE, GEORGIA, A LABEL IDENTIFYING THE SPARE TIRE AS A TEMPORARY USE SPARE TIRE WAS NOT INSTALLED. THE UPGRADE INCLUDES 4 LARGER SIZE TIRES WITH ALLOY WHEELS. THE ORIGINAL SPARE TIRE/STEEL WHEEL IS NOT PART OF THE UPGRADE AND WAS NOT CHANGED.

Consequence:

DIFFERENT OPERATING CHARACTERISTICS CAN BE EXPERIENCED WHEN THE SPARE TIRE IS INSTALLED ON THE VEHICLE.

Action:

OWNERS WILL BE PROVIDED WITH A CAUTION LABEL AND AN INSERT FOR THEIR OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.