Ford Buyers Guide

 

 2007 Ford Escape Limited FWD

*
MSRP: $24,650
Invoice: $23,204

Gas Mileage:
CTY: 20    HWY: 24    CMB: 22
Engine/Fuel: 6 Cyl Gas
Transmission: A
Door/Body Style: 4 Door/Sport Utility,SPE,SPE,Crossover, CUV
Drive Type: FWD

Prices/Warranty

See the prices and various warranties offered.
  • General
  • MSRP: $24,650
  • Invoice Price: $23,204
  • Destination Charge: $0
  • Warranty
  • Basic (Month): 36
  • Basic (Mileage): 36000
  • Powertrain (Month): 60
  • Powertrain (Mileage): 60000
  • Rust (Month): 60
  • Rust (Mileage):  

Engine & Emissions

View engine and emission data on this vehicle.
  • Engines & Emissions
  • 100,000-Mile Extended Service Interval For Tune-Up
  • 3.0-Liter Duratec, V6, 24-Valve, DOHC, SEFI Engine; Front Mounted With Horsepower Of 200@6000, Torque Of 193@4850, Alloy Block and Alloy Cylinder Heads
  • Emergency Reduced Engine Power
  • Engine
  • Type of Engine: 3.0L V6
  • Displacement (CC): 3000
  • Fuel System: SEFI
  • Horsepower @ RPM: 200@6000
  • Torque @ RPM: 193@4850
  • Turbo: N
  • Compression ratio: 10.0
  • Cylinders: 6
  • RPM @ Peak Horsepower: 6000
  • Bore X Stroke: 3.50x3.13
  • Fuel Type: Gas

Dimensions

See the interior and exterior dimensions.
  • Exterior Dimensions
  • Track Front: 61.3
  • Track Rear: 60.9
  • Ground Clearance (in): 8.2
  • Overall Length (in): 174.9
  • Overall Width (in): 70.1
  • Overall Height (in): 69.7
  • Wheelbase (in): 103.1
  • Curb weight (lbs): 3300
  • Interior Dimensions
  • Seating capacity - Standard: 5
  • Seating Capacity - Maximum: 5
  • Headroom front (in): 40.4
  • Headroom rear (in): 39.2
  • Hip room front (in): 53.4
  • Hip room rear (in): 49.1
  • Leg room front (in): 41.6
  • Leg room rear (in): 35.6
  • Shoulder room front (in): 56.3
  • Shoulder room rear (in): 55.9

Features

See the features of this vehicle.
  • Exterior Features
  • Bodyside/Cab Step or Running Board: N/A
  • Bumper Step Up: Standard
  • Front Air Dam: Standard
  • Metallic Paint: Standard
  • Power Sliding Side Van Door: N/A
  • Power Trunk Lid: N/A
  • Rear Spoiler: N/A
  • Skid Plate or Underbody Protection: N/A
  • Splash or Mud Guards: N/A
  • Wind Deflector or Buffer for Convertibles: N/A
  • Exterior
    • A-Gloss Body Color Door Handles
    • Automatic Headlights With Automatic Off and Time Delay
    • Black Surround Grille With Black Mesh Center
    • Body Color Body Side Cladding and Wheel Lip Moldings
    • Body Color Liftgate Molding
    • Front Air Dam
    • Front and Rear Body Color 2.5-MPH Impact-Absorbing Bumpers
    • Front Foglights
    • Halogen Headlights
    • Metallic Paint (If Selected)
    • Perimeter Lighting
    • Rear Step Up Bumper
    • V6 Badging
  • Heating, Ventilation & Air Conditioning
  • Air Conditioning: Standard
  • Automatic Climate Control: N/A
  • Interior Pollen/Particle/Dust Air Filter: Not listed
  • Rear Heating, Ventilation & Air Conditioning: Standard
  • Rear HVAC Ducts: Standard
  • Rear Seat HVAC Controls: N/A
  • Heating, Ventilation & Air Conditioning
    • Manual Air Conditioning
    • Rear Heating Ducts
  • Entertainment
  • Cassette Player: N/A
  • CD Changer: Standard
  • CD Player: Standard
  • DVD Player: N/A
  • Hands Free or Voice Activated Phone: N/A
  • Navigational Aid: N/A
  • Radio: Standard
  • Second Row Sound Controls/Accessories: N/A
  • Subwoofer: Option
  • Telematic Systems: N/A
  • Entertainment, Communication & Navigation
    • AM/FM Radio With 4 Speakers Total; 6-Disc CD Changer; MP3 Player
    • Radio Antenna
    • Radio Data System
  • Instrumentation
  • Battery Gauge: N/A
  • Clock: Standard
  • Compass: Standard
  • Cruise Control: Standard
  • Electroluminescent Instrumentation: N/A
  • Gauges: Standard
  • Inside Temperature Gauge: N/A
  • Intelligent Cruise Control: N/A
  • Night Vision: N/A
  • Oil Gauge: N/A
  • Outside Temperature Gauge: N/A
  • Service or Maintenance Interval Indicator: Standard
  • Steering Wheel Mounted Controls: Standard
  • Tachometer: Standard
  • Tire Inflation/Pressure Monitor: Standard
  • Trip Computer: N/A
  • Instrumentation
    • Audible Warnings Include Beltminder(TM) Seatbelts Unfastened
    • Compass
    • Cruise Control
    • Digital Clock
    • Maintenance Interval Indicator
    • Steering Wheel Mounted Controls For Cruise Control
    • Tachometer
    • Tire Pressure Monitor
    • Trip Computer With Average Fuel Consumption, Miles To Empty and Instantaneous Fuel Consumption
    • Warning Lights Include Brake System, Oil Pressure, Electrical System, Low Fuel and Door Ajar
  • Lighting
  • Automatic Headlights: Standard
  • Cornering Lights: N/A
  • Daytime Running Lights: N/A
  • Fog Lights: Standard
  • Halogen Headlights: Standard
  • Headlight Washers: N/A
  • High Intensity Discharge Headlights: N/A
  • Windshield Wiper Activated Headlights: N/A
  • Roof
  • Power Sunroof/Moonroof: Option
  • Removable/Convertible Top: N/A
  • Sunroof/Moonroof: Option
  • Wheels & Tires
  • Alloy Wheels: Standard
  • Chrome Wheels: N/A
  • Exterior Rear Mounted Tire Carrier: N/A
  • Full Size Spare Tire: Option
  • Interior Spare Tire for SUVs & Vans: N/A
  • Self Sealing/Run Flat Tires: N/A
  • Steel Wheels: N/A
  • Underbody Tire Carrier: Standard
  • Wheels & Tires
    • Bright Machined Alloy Wheels, 16-In.
    • Compact Spare Tire
    • SBRP235/70R16 BSW, All-Season Tires
    • Underbody Tire Carrier
  • Windows, Mirrors & Wipers
    • Exterior Auto Day/Night/Electrochromic Mirrir
    • Glass Rear Window on Convertible
    • Heated Exterior Mirror
    • Heated Washer System
    • Heated Windshield Glass
    • Interior Auto Day/Night/Electrochromic Mirror
    • Interval Wipers
    • Oversize or Wide Angle Exterior Mirror
    • Power Adjustable Exterior Mirror
    • Power Backlight Window
    • Rain Sensing Wipers
    • Rear Wiper
    • Sliding Rear Pickup Truck Window
    • Tinted Glass
    • Vehicle Speed Sensing Wiper Interval
    • Windshield Wiper De-Icer
  • Windows/Mirrors/Wipers
  • Exterior Auto Day/Night/Electrochromic Mirrir: N/A
  • Glass Rear Window on Convertible: N/A
  • Heated Exterior Mirror: Option
  • Heated Washer System: N/A
  • Heated Windshield Glass: N/A
  • Interior Auto Day/Night/Electrochromic Mirror: Standard
  • Interval Wipers: Standard
  • Oversize or Wide Angle Exterior Mirror: N/A
  • Power Adjustable Exterior Mirror: Standard
  • Power Backlight Window: N/A
  • Rain Sensing Wipers: N/A
  • Rear Wiper: Standard
  • Sliding Rear Pickup Truck Window: N/A
  • Tinted Glass: Standard
  • Vehicle Speed Sensing Wiper Interval: N/A
  • Windshield Wiper De-Icer: N/A
  • Windows, Mirrors & Wipers
    • Dual Black Folding Power Adjustable Exterior Rearview Mirrors
    • Electrochromic Interior Rearview Mirror
    • Flip-Up Liftgate Window
    • Front Dual Cloth Sunvisors
    • Front Dual Illuminated Vanity Mirrors
    • Power Window Lockout/Override
    • Power Windows With Driver One-Touch Down
    • Rear and Side Privacy Glass
    • Rear and Side Tinted Glass
    • Rear Window Defroster
    • Rear Window Variable Intermittent Wiper/Washer
    • Variable Intermittent Windshield Wipers

Safety Features

View the built in safety features included.
  • Safety Features
  • Automatic Locking Retractors
  • Crash Sensor
  • Crumple Zones
  • Driver Airbag With Dual Stage Deployment
  • Emergency Fuel Shut-Off Device
  • Front and Rear Outboard 3-Point Seatbelts
  • Front Seatbelt Height Adjusters
  • Front Seatbelt Pretensioners With Force Limiters
  • L A T C H
  • Passenger Airbag Cutoff Sensor
  • Passenger Airbag With Dual Stage Deployment
  • Personal Safety System(TM) Includes Pretensioners With Load Limiters, Driver Airbag With Dual Stage Deployment, Passenger Airbag With Dual Stage Deployment, Front Passenger Seat Position Sensor and Crash Sensor
  • Rear 3-Point Center Seatbelt
  • Side Guard Door Beams
  • Anti-Theft
  • Child Safety Door Locks Located On Rear Doors
  • Power Door Locks
  • Power Tailgate Lock/Unlock
  • SecuriLock(TM) Vehicle Anti-Theft Via Engine Immobilizer and Perimeter Alarm
  • Selective Locking/Unlocking
  • Braking & Traction
  • 4-Wheel Anti-Lock Brakes
  • Electronic Brake Assistance
  • Front Power 277-mm Vented Disc and Rear Power Drum Brakes

Read Reviews

Expert opinions you can trust.

*Fuel Economy Guide

Research the yearly spend on gasoline for every Ford in our database.

  • The fuel economy calculations assume annual mileage of 15,000 miles, 45% of which is highway miles and 55% city miles and fuel costs of $2.79 per gallon. These figures can be adjusted to more accurately reflect your driving style and fuel costs in your area:

     






 

*NHTSA Test Results

Get crash test results, service bulletins, and product recalls for every Ford model.

  • Click a car name to see the crash test details for that model.

     

     

    Crash Test Data for 2007 Ford

    Ford Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
    Driver Passenger Front Seat Rear Seat
    2007 Crown Victoria
    2007 Crown Victoria
    2007 E-150Not
    Tested    		Not
    Tested    		Not
    Tested    		Not
    Tested
    2007 E-350 15 PassengerNot
    Tested    		Not
    Tested    		Not
    Tested    		Not
    Tested
    2007 Edge
    2007 Escape
    2007 Escape HybridNot
    Tested
    2007 ExpeditionNot
    Tested    		Not
    Tested
    2007 Explorer
    2007 Explorer Sport Trac
    2007 F-150Not
    Tested    		Not
    Tested
    2007 F-150Not
    Tested    		Not
    Tested
    2007 F-150Not
    Tested    		Not
    Tested
    2007 Five Hundred
    2007 Five Hundred
    2007 Focus
    2007 Focus
    2007 Freestar
    2007 Freestyle
    2007 Freestyle
    2007 Fusion
    2007 MustangNot
    Tested    		Not
    Tested    		Not
    Tested    		Not
    Tested
    2007 MustangNot
    Tested
    2007 RangerNot
    Tested
    2007 RangerNot
    Tested
    2007 Taurus
    2007 Taurus

     

    Service Bulletins for 2007 Ford

    2007 FORD 500
    Bulletin Number: CSP-12N03
    FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY
    2007 FORD CROWN VICTORIA
    Bulletin Number: 06203
    ENGINE COOLING FAN INOPERATIVE - ENGINE OVERHEATING - POOR A/C PERFORMANCE. *KB
    Bulletin Number: 062512
    REDUCTION IN POWER AT WIDE OPEN THROTTLE. *KB
    Bulletin Number: 06391
    TRANSMISSION OIL COOLER BYPASS VALVE INSPECTION - PROGRAM EXPIRATION EXTENSION. *KB
    Bulletin Number: 07212
    SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
    Bulletin Number: 07226
    MALFUNCTION INDICATOR LAMP (MIL) ON--DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P061B--POLICE INTERCEPTOR BUILT BEFORE 10/19/2007. *NJ
    Bulletin Number: 0795
    ENGINE OVERHEATING-POOR A/C PERFORMANCE. *KB
    Bulletin Number: 19299
    ENGINE COOLING FAN (8C607) INOPERATIVE. *KB
    Bulletin Number: 19522
    AIR BAG INDICATOR LIGHT ILLUMINATED. *KB
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 20144
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: CSP-09N02
    FORD: PERFORMANCE WHITE OR VIBRANT WHITE PAINT PEELING. IN SOME AFFECTED VEHICLES, THE PERFORMANCE WHITE OR VIBRANT WHITE PAINT MAY NOT HAVE BEEN APPLIED PROPERLY AND MAY PEEL ON THE UPPER HORIZONTAL SURFACES DUE TO THE EXCESSIVE HEAT AN
    Bulletin Number: RP-13-R-01
    FORD: SWING LINK JOINTS ON LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION, AND COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, ON SOME VEHICLES, CAUSES STEERING COLUMN TO SEPARATE, LEADING TO STEERING CONTROL LOSS. MODEL 2005
    Bulletin Number: RP-13R01
    FORD: THE LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION OF SWING LINK JOINTS, COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, RESULTING IN STEERING COLUMN SEPARATION AND LOSS OF STEERING CONTROL. MODEL 2005-2011 CROWN VICTOR
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: TSB-08-18-2
    FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *
    Bulletin Number: TSB-12-7-4
    FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo
    2007 FORD E-150
    Bulletin Number: 0703
    CERTAIN 2007 E-SERIES STRIP CHASSIS VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 19527
    HEADLIGHT ADJUSTMENT NEEDED. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19845
    CRANK/NO START/ NO PCM COMMUNICATION AND POSSIBLY P1336 AND OTHER CODES. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: TSB-10-17-7
    FORD: THERE ARE DRIVEABILITY CONCERNS SUCH AS HESITATION, LOW IDLE, OR LOSS OF POWER. 2007-2008 E150/250. *RM
    Bulletin Number: TSB T2007-02
    ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND T
    2007 FORD E-250
    Bulletin Number: 0703
    CERTAIN 2007 E-SERIES STRIP CHASSIS VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 19527
    HEADLIGHT ADJUSTMENT NEEDED. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19845
    CRANK/NO START/ NO PCM COMMUNICATION AND POSSIBLY P1336 AND OTHER CODES. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: TSB-10-17-7
    FORD: THERE ARE DRIVEABILITY CONCERNS SUCH AS HESITATION, LOW IDLE, OR LOSS OF POWER. 2007-2008 E150/250. *RM
    Bulletin Number: TSB T2007-02
    ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND T
    2007 FORD E-350
    Bulletin Number: 0703
    CERTAIN 2007 E-SERIES STRIP CHASSIS VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19527
    HEADLIGHT ADJUSTMENT NEEDED. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19845
    CRANK/NO START/ NO PCM COMMUNICATION AND POSSIBLY P1336 AND OTHER CODES. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: TSB-08-16-13
    FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE
    Bulletin Number: TSB-08-18-6
    FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
    Bulletin Number: TSB-08-20-1
    FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
    Bulletin Number: TSB-08-26-3
    FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    Bulletin Number: TSB-10-12-6
    FORD: RUNS ROUGH, LACKS POWER, HARD START, NO START. SOME VEHICLES AND TRUCKS EQUIPPED WITH 6.0L ENGINE MAY EXHIBIT A RUNS ROUGH, LACKS POWER, HARD TO START, NO START CONCERN WITH OR WITHOUT DIAGNOSTIC TROUBLE CODE (DTC) P0611 CODE OR VAR
    Bulletin Number: TSB-10-23-5
    FORD: THERE MAY BE A LACK OF RPM, HESITATION, OR ROUGH RUNNING CONCERNS WHEN THE VEHICLE IS IN IDLE. THERE MAY BE TWO TROUBLE CODES STORED. THE PROBLEM MAY BE CAUSED BY AFTERMARKET GENERATORS INSTALLED OR MODIFICATIONS TO THE FRONT END DRIV
    Bulletin Number: TSB T2007-02
    ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND T
    2007 FORD E-350 BUS
    Bulletin Number: 06229
    6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
    Bulletin Number: 0703
    CERTAIN 2007 E-SERIES STRIP CHASSIS VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 0714
    LACK OF COOLING FAN OPERATION. *KB
    2007 FORD E-450
    Bulletin Number: 06229
    6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
    Bulletin Number: 0703
    CERTAIN 2007 E-SERIES STRIP CHASSIS VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 0714
    LACK OF COOLING FAN OPERATION. *KB
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19527
    HEADLIGHT ADJUSTMENT NEEDED. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19845
    CRANK/NO START/ NO PCM COMMUNICATION AND POSSIBLY P1336 AND OTHER CODES. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: TSB-08-16-13
    FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE
    Bulletin Number: TSB-08-18-6
    FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
    Bulletin Number: TSB-08-20-1
    FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
    Bulletin Number: TSB-08-26-3
    FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
    Bulletin Number: TSB-10-12-6
    FORD: RUNS ROUGH, LACKS POWER, HARD START, NO START. SOME VEHICLES AND TRUCKS EQUIPPED WITH 6.0L ENGINE MAY EXHIBIT A RUNS ROUGH, LACKS POWER, HARD TO START, NO START CONCERN WITH OR WITHOUT DIAGNOSTIC TROUBLE CODE (DTC) P0611 CODE OR VAR
    Bulletin Number: TSB-10-23-5
    FORD: THERE MAY BE A LACK OF RPM, HESITATION, OR ROUGH RUNNING CONCERNS WHEN THE VEHICLE IS IN IDLE. THERE MAY BE TWO TROUBLE CODES STORED. THE PROBLEM MAY BE CAUSED BY AFTERMARKET GENERATORS INSTALLED OR MODIFICATIONS TO THE FRONT END DRIV
    Bulletin Number: TSB T2007-02
    ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND T
    2007 FORD E-550
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: TSB-08-20-1
    FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
    Bulletin Number: TSB-08-26-3
    FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
    Bulletin Number: TSB T2007-02
    ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND T
    2007 FORD EDGE
    Bulletin Number: 07119
    FORD STATES BRAKE DRAG MAY CAUSE AN ODOR OR REDUCED POWERTRAIN PERFORMANCE. THIS COULD ALSO CAUSE THE INTEGRAL VEHICLE DYNAMICS (IVD) LIGHT AFTER DRIVING A GIVEN DISTANCE DUE TO PRESSURE NOTED IN THE MODULE *NJ
    Bulletin Number: 0713
    POWER STEERING FLUID LEAKS FROM STEERING RACK AND PUMP ATTACHMENT JOINTS. *KB UPDATED 2/27/08. *NJ
    Bulletin Number: 07172
    SOME 2007 EDGE/MKX VEHICLES BUILT BEFORE 6/1/07 (FWD ONLY) MAY EXHIBIT AN ABS LAMP ON C1165/C1175 AND/OR C1235/C1236. *NJ
    Bulletin Number: 07179
    PCM-BATTERY JUNCTION BOX (BJB)- POSSIBLE MIL ON WITH MULTIPLE DTCS, NO CRANK/NO START, DRIVABILITY SYMPTOMS. *NJ
    Bulletin Number: 07311
    6F50 TRANSAXLES BUILT PRIOR TO 1/1/07 - DTC P0715, P0717, P0718, P0720, AND/OR HARSH ENGAGEMENT, NO UPSHIFT, FIFTH GEAR ONLY. *KB UPDATED 2/6/08. *NJ
    Bulletin Number: 0746
    CERTAIN 2007 MODEL YEAR LINCOLN MKX AND FORD EDGE VEHICLES EQUIPPED WITH TIRE PRESSURE MONITOR SYSTEM (TPMS) - TPMS ACTIVATION. *NJ
    Bulletin Number: 0752
    DTC P0771, P0774 AND / OR STARTS IN 4TH GEAR FROM A STOP, HARSH 4-1 DOWNSHIFT ON DRIVE AWAY AT 3 MPH. 6F50 TRANSAXLE BUILT PRIOR TO 01-10-07. *KB
    Bulletin Number: 14R02
    Certain 2007-2008 Model Year Edge and MKX Vehicles Not Covered Under Safety Recall 14S22 Fuel Tank Corrosion Inspection and Repair road salt use, moisture and salt may become trapped under the fuel tank mounting reinforcement brackets a
    Bulletin Number: 14S22
    Fuel Tank Corrosion Inspection and Repair REASON FOR THIS PROGRAM In some of the affected vehicles that are operated in high-corrosion environments associated with road salt use, moisture and salt may become trapped under the fuel tank
    Bulletin Number: 17B23
    Certain 2006-2008 Model Year Fusion and Milan, 2006 Zephyr, 2007-2008 MKZ and 2007-2008 Edge, MKX and Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 17B23-S1
    Certain 2006-2008 Model Year Fusion and Milan, 2006 Zephyr, 2007-2008 MKZ and 2007-2008 Edge, MKX and Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 19623
    USE TWO REAR WHEEL HUB NUTS (INNER AND OUTER). ON ALL WHEEL DRIVE VEHICLES. *KB
    Bulletin Number: 19715
    INSTRUMENT PANEL LIGHTS DIM - SPDJB MUST LEARN RESISTANCE VALUES OF DIMMER. *KB
    Bulletin Number: 20003
    6F50 TRANSAXLE EQUIPPED VEHICLES WHEN STOPPED ON A HILL IN DRIVE OR REVERSE WITHOUT SERVICE BRAKE APPLIED MAY ROLL (WON'T HOLD). *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44649
    FORD: A JOB AID WAS DEVELOPED AND NOW AVAILABLE FOR THE PTU INTERNAL OR EXTERNAL FLUID LEAKAGE FOR ALL WHEEL DRIVE VEHICLES. *PE
    Bulletin Number: SB-20725
    FORD: SOME VEHICLES MAY EXHIBIT A GROWL/HOWL TYPE NOISE COMING FROM THE LEFT AND/OR RIGHT REAR WHEEL AREA. *PE
    Bulletin Number: SI-20010
    FORD: SOME MULTIPLES VEHICLES REPLACEMENTS MAY REQUIRE REVISED AS BUILT DATA. THE NEW LEVEL SJB SERVICE PART INTRODUCED BETWEEN 10/07 AND 02/08 WILL REQUIRE ENTRY OF AS BUILT DATA. *PE
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46412
    SOME 2007-2016 EDGE/MKX/FLEX/MKT/MKZ/MKS/TAURUS/TAURUS POLICE/EXPLORER/EXPLORER POLICE EQUIPPED WITH ALL WHEEL DRIVE (AWD) AND BUILT ON OR BEFORE 30-JUN-2016 MAY EXHIBIT A TICKING AND/OR KNOCKING NOISE COMING FROM THE DRIVELINE AREA. TO IDE
    Bulletin Number: SSM 47230
    Some 2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Police Interceptor Sedan/Explorer/Police Interceptor Utility vehicles equipped with AWD and built on or before 30-Jun-2016 may exhibit a propane or natural gas odor during idle or low speed dr
    Bulletin Number: TSB-10-16-1
    FORD: THERE MAY BE A ROUGH IDLE OR MISSES WHILE THE MALFUNCTION LIGHT IS ON. THERE ARE MUTLIPLE POSSIBLE TROUBLE CODES STORED. *RM
    Bulletin Number: TSB-13-4-17
    FORD/LINCOLN/MERCURY: SOME VEHICLES, WITH DIAGNOSTIC CODES (DTCS) P0351, P0352, P0353, P0354, P0355, MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP IN THE POWERTRAIN CONTROL MODULE (PCM) AND ONE OR MORE COIL ON PLUG(S) DAMAGE. MODELS 2006-08
    Bulletin Number: TSB-14-0098
    FORD/LINCOLN: SOME VEHICLES ARE EXPERIENCING A TYPE OF NOISE, A HOWL OR GROWL, EMITTING FROM THE DRIVER OR PASSENGER REAR WHEEL AREA. MODEL 2007-2010 EDGE, MKX. *PE
    2007 FORD ESCAPE
    Bulletin Number: 06166
    POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB
    Bulletin Number: 06181
    MISFIRE DTC'S P0316, P0300, P0301, P0302, P0303, AND P0304. *KB
    Bulletin Number: 07111
    COLD CLIMATE SLOW FUEL FILL. *NJ
    Bulletin Number: 0748
    SERVICE HARNESS INSTALLATION - CORROSION OF A RESISTOR IN THE BATTERY POWER UNIT. ALSO HAVE AN OWNER'S LETTER. *NJ
    Bulletin Number: 0756
    ENGINE STALLING ON ENGAGEMENT/STOPPING. *KB
    Bulletin Number: 08-3-1
    MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) U2062 (HYBRID ONLY). *NJ
    Bulletin Number: 08-5-5
    SLOW FUEL FILL AND/OR DTC P0451. *NJ
    Bulletin Number: 19355
    DRIVEABILITY CONCERNS AND/OR DTCP0340 - INSPECT CRANKSHAFT PULLEY. *KB
    Bulletin Number: 19536
    SLOW FUEL FILL DUE TO CLOGGED VENT. *KB
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 19956
    2005-2008 ESCAPE HYBRID AND 2006-2008 MARINER HYBRID VEHICLES ARE NOT E-85 COMPATIBLE. *NJ
    Bulletin Number: 20144
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 20213
    2005-08 ESCAPE/ESCAPE HYBRID/MARINER - 2006-08 MARINER HYBRID - WHEEL SPEED SENSOR RING REPLACEMENT PROCEDURE UPDATE TO WORKSHOP MANUAL. *NJ
    Bulletin Number: AS-21534
    FORD: THERE IS EXCESSIVE ENGINE OR EXHAUST NOISE, OR AN EXHAUST ODOR DUE TO AN EXHAUST LEAK. THERE WILL BE NO WARNING CODES OR LIGHTS. 2007-2008 ESCAPE/MARINER. *RM
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44649
    FORD: A JOB AID WAS DEVELOPED AND NOW AVAILABLE FOR THE PTU INTERNAL OR EXTERNAL FLUID LEAKAGE FOR ALL WHEEL DRIVE VEHICLES. *PE
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: TSB-07-21-11
    FORD/MERCURY/LINCOLN: SOME VEHICLES EQUIPPED WITH A 6F50 TRANSAXLE , WITH ANY OUTPUT SHAFT SPEED (OSS) SENSOR OR TURBINE SHAFT SPEED (TSS) SENSOR DIAGNOSTIC TROUBLE CODE(S) (DTCS) P0715, P0717, P0720, P0721, P0722 AND/OR HARSH ENGAGEMENTS,
    Bulletin Number: TSB-09-21-9
    FORD/MERCURY: NEW SERVICE KIT AVAILABLE FOR ACCELERATOR CABLE TO PEDAL CONNECTION. SOME VEHICLES MAY REQUIRE THE ACCELERATOR CABLE TO ACCELERATOR PEDAL CONNECTION REPAIRED. A NEW SERVICE CLIP HAS BEEN RELEASED FOR USE, IN LIEU OF REPLACI
    Bulletin Number: TSB-12-4-8
    FORD: SOME MODEL VEHICLES WOULD LOSE 2ND AND 4TH GEAR ON A CD4E TRANSMISSION. MODEL ESCAPE 2007-2008. *PE
    2007 FORD ESCAPE HEV
    Bulletin Number: 19536
    SLOW FUEL FILL DUE TO CLOGGED VENT. *KB
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    2007 FORD ESCAPE HYBRID
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-22242
    FORD/MERCURY: SOME HYBRID VEHICLES MAY REQUIRE A UNIQUE BLEED PROCEDURE AFTER A REPLACEMENT FOR ONE OR MORE OF HYDRAULIC BRAKE SYSTEM COMPONENTS. *PE
    Bulletin Number: SSM-45870
    2005-2008 ESCAPE/MARINER HYBRID - ANTI-LOCK BRAKE SYSTEM (ABS) WARNING INDICATOR ILLUMINATED WITH DTC(S) C1478, C1479, C1480 AND/OR C1481
    Bulletin Number: TSB-08-24-5
    FORD/MERCURY: VEHICLES MAY EXHIBIT A RED TRIANGLE LIGHT AND CODES INDICATING A TRANSAXLE OVERTEMP. CONDITION MAY RESULT IN REDUCED POWER AS SYSTEM ACTIVATES FAIL SAFE OPERATION. *PE
    Bulletin Number: TSB-09-15-3
    FORD/MERCURY: SOME VEHICLES MAY SET DIAGNOSTIC TROUBLE CODES (DTCS) P0A81 (BATTERY PACK COOLING FAN 1 CONTROL CIRCUIT) AND/OR P0A96 (BATTERY PACK COOLING FAN 2 CONTROL CIRCUIT) IN THE TRACTION BATTERY CONTROL MODULE (TBCM). THESE CODES BY
    Bulletin Number: TSB 16-0118
    Some 2005-2012 Escape Hybrid and 2006-2011 Mariner Hybrid vehicles may set DTCs P0A81 (battery pack cooling fan 1 control circuit) and/or P0A96 (battery pack cooling fan 2 control circuit) in the traction battery control module (TBCM). Thes
    2007 FORD E-SERIES
    Bulletin Number: 07212
    SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: SB-09M02
    FORD: CERTAIN VEHICLES WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT; SPECIFIC COMPONENT WARRANTY EXTENSION. AWARENESS COMMUNICATION, DATED 4/20/09. *PE
    Bulletin Number: SB-09M03
    FORD: CERTAIN VEHICLES, E SERIES AND F SUPER DUTY, WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT-6.0L DIESEL ENGINE REPLACEMENT WARRANTY EXTENSION. AWARENESS COMMUNICATION DATED 4/20/09. *PE
    Bulletin Number: SB-20937
    FORD: MULTIPLE VEHICLES WITH A TORQ SHIFT TRANSMISSION INTERMITTENT CLUNK WHEN SHIFTING BETWEEN DRIVE, REVERSE AND PARK AND/OR DURING 2-3 UPSHIFT. MODELS F SUPER DUTY; E SERIES; EXCURSION; F53 MOTORHOME CHASSIS AND LOW CAB FORWARD.
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: TSB-08-23-8
    FORD: VEHICLES MAY EXHIBIT FUEL IN THE ENGINE COOLANT, DUE TO LEAKS IN THE CYLINDER HEAD FUEL INJECTOR AREA. SYMPTOMS MAY INCLUDE FUEL IN ENGINE COOLANT AND COOLANT EXPULSION FROM THE DEGAS BOTTLE. *PE UPDATED 3/20/09.
    Bulletin Number: TSB-11-11-21
    FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE
    2007 FORD EXPEDITION
    Bulletin Number: 07256
    ABS LIGHT ON--VEHICLES BUILT BEFORE 2/15/2007. *NJ
    Bulletin Number: 0755
    6R75 TRANSMISSION 2 - 3 AND / OR 4 - 5 SHIFT FLARE, POSSIBLE WRENCH LAMP ILLUMINATED WITH DTC P0782 AND / OR P0784. *KB
    Bulletin Number: 07811
    HARSH 1-2 AND/OR 2-1 SHIFTS, TIP-IN HESITATION OR SURGE, AND/OR LONG ENGAGEMENT TIME. *KB
    Bulletin Number: 19615
    REAR WHEEL SPEED SENSOR REPAIR RECOMMENDATION. *KB
    Bulletin Number: 19715
    INSTRUMENT PANEL LIGHTS DIM - SPDJB MUST LEARN RESISTANCE VALUES OF DIMMER. *KB
    Bulletin Number: 19778
    BUCK/JERK/HESITATION - LESS THAN 1/4 TANK OF FUEL. *KB
    Bulletin Number: 19843
    2007 EXPEDITION - PCM RUNNING CHANGE *NJ
    Bulletin Number: 20554
    FORD: VEHICLES WITH ANTI-LOCK BRAKE CONTROL SYSTEM DTC C2777. MAY EXHIBIT AN ANTI-LOCK BRAKE CONTROL SYSTEM (ABS) LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE DTC C2777. PINPOINT TEST G IN WORK SHOP MANUAL SECION 206-09. *PE
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44669
    FORD/LINCOLN: THERE WILL BE 2 NEW PIECE RECEIVER DRYER DESICCANT BAG THAT WILL REPLACE 1 PIECE RECEIVER DRY CARTRIDGE, WHICH ARE INTERCHANGABLE, FULLY, DO NOT AFFECT FORM, FIT, OR FUNCTION. MODEL 2011-14 F-SUPER DUTY, 2009-14 F150, 2007-1
    Bulletin Number: SI-20002
    FORD: VARIOUS TRANSMISSION SHIFT QUALITY SYMPTOMS- 6R75 TRANSMISSION- TEMPORARY DO NOT ATTEMPT TO REPAIR. WHEN COMPARED TO OTHER TRANSMISSIONS, SOME OF THE SHIFT CHARACTERISTICS ARE DIFFERENT THAN PREVIOUS MODELS DUE TO THE 100% SYNCHRONO
    Bulletin Number: SI-20008
    FORD: WATER LEAKS, WIND NOISE AND/OR NOISE ON OPENING/CLOSING THE MOON ROOF/ROOF OPENING PANEL. THE 2004-07 WSM MANUAL PROVIDES TWO SEPARATE PROCEDURES FOR MOON ROOF HEIGHT A HORIZONTAL ADJUSTMENTS. HEIGHT AND HORIZONTAL PROCEDURES NEED TO
    Bulletin Number: SI-20010
    FORD: SOME MULTIPLES VEHICLES REPLACEMENTS MAY REQUIRE REVISED AS BUILT DATA. THE NEW LEVEL SJB SERVICE PART INTRODUCED BETWEEN 10/07 AND 02/08 WILL REQUIRE ENTRY OF AS BUILT DATA. *PE
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46542
    When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The update
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-08-14-2
    FORD/LINCOLN: STABILITY/TRACTION CONTROL INDICATOR; SLIDING CAR ICON: ON OR FLASHING; DTC C1996 OR SENSITIVE ESC/RSC ACTIVATION NO CODES. AFFECT SOME 2007-2008 EXPEDITIONS AND NAVIGATORS. *PE
    Bulletin Number: TSB-08-19-3
    FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE
    Bulletin Number: TSB-08-20-8
    FORD: STEERING WHEEL ANGLE CIRCUIT AND/OR SIGNAL FAILURE-C1277-C1278-BUILT ON OR BEFORE 4/10/08. VEHICLES MAY EXHIBIT A TRACTION CONTROL LIGHT (TCL) ON WITH DIAGNOSTIC TROUBLE CODES. *PE
    Bulletin Number: TSB-08-9-1
    FORD/LINCOLN: EATC BLOWER INTERMITTENTLY INOPERATIVE-STUCK ON HIGH/OFF. BLOWER MOTOR IS INOPERATIVE NO MATTER WHAT SPEED OR TEMP SETTING OR THE BLOWER MOTOR IS STUCK ON HIGH SPEED OR OFF. *PE
    Bulletin Number: TSB-09-19-12
    FORD: SOME HYBRID VEHICLES MAY EXHIBIT AN INTERMITTENT RED TRIANGLE ON AND STOP SAFELY NOW MESSAGE DISPLAYED ON THE MESSAGE CENTER, ACCOMPANIED BY A SUDDEN RPM LOSS/NO START WITH A DIAGNOSTIC TROUBLE CODE (DTC) P1A0C. *PE
    Bulletin Number: TSB-10-18-1
    FORD: SOME EXPEDITION, F-150, AND NAVIGATOR MODELS MAY EXPERIENCE A DELAYED FORWARD OR REVERSE TRANSMISSION ENGAGEMENT. USUALLY HAPPENS ON COLD START IN COLD CLIMATES. *RM
    Bulletin Number: TSB-10-18-1
    FORD: SOME EXPEDITION/NAVIGATOR/F150 VEHICLES MAY HAVE A DELAYED FORWARD/REVERSE ENGAGEMENT WITH STORED TROUBLE CODES. *RM
    Bulletin Number: TSB-14-0114
    LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
    Bulletin Number: TSB-18-16-14
    FORD: SOME EXPEDITION AND NAVIGATOR VEHICLES MAY EXHIBIT THE MALFUNCTION INDICATOR LIGHT (MIL) ON WITH DTC P0345 AND/OR P0349 WITHOUT ANY DRIVEABILITY SYMPTOMS. *PE
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo
    2007 FORD EXPLORER
    Bulletin Number: 06167
    MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB
    Bulletin Number: 061710
    MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB
    Bulletin Number: 061713
    CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE. *KB
    Bulletin Number: 062414
    LOWER STEERING COLUMN SHAFT POP/CLUNK NOISE. *KB
    Bulletin Number: 07253
    FUEL FILL--SLOW OR EARLY SHUT OFF--BUILT BEFORE 11/28/2007. *NJ
    Bulletin Number: 0728
    OVERHEAT INDICATION AND SHIFT QUALITY IMPROVEMENTS - CALIBRATION UPDATE RELEASE - 4.6L 3V WITH 6R60 TRANSMISSION EQUIPPED VEHICLES ONLY. *KB
    Bulletin Number: 0773
    FRONT SEAT MANUAL LUMBAR INOPERATIVE. *KB
    Bulletin Number: 0782
    THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C. *KB
    Bulletin Number: 08-2-8
    IMPROVED BRAKE PEDAL FEEL AND FIRMNESS. *NJ
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 20144
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44429
    FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC.
    Bulletin Number: DOR-S3J9G-11
    This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
    Bulletin Number: SI-20005
    FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. WHEN COMPARED TO OTHER TRANSMISSIONS, SOME OF THE SHIFT CHARACTERISTICS ARE DIFFERENT THAN PREVIOUS MODELS DUE TO THE 100% S
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46412
    SOME 2007-2016 EDGE/MKX/FLEX/MKT/MKZ/MKS/TAURUS/TAURUS POLICE/EXPLORER/EXPLORER POLICE EQUIPPED WITH ALL WHEEL DRIVE (AWD) AND BUILT ON OR BEFORE 30-JUN-2016 MAY EXHIBIT A TICKING AND/OR KNOCKING NOISE COMING FROM THE DRIVELINE AREA. TO IDE
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-08-18-2
    FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *
    Bulletin Number: TSB-08-19-3
    FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE
    Bulletin Number: TSB-08-9-5
    FORD/MERCURY: 4.0L/4.6L HARD START/ROUGH RUNNING; AFTER LONG HOT SOAK/DIP IN RPM WHEN COMING TO A STOP; BUILT ON OR BEFORE 4/2/08. MAY EXHIBIT A DIP IN RPM BELOW NORMAL IDLE LEVEL OF 600 RPM ON DECELERATION. *PE
    Bulletin Number: TSB-12-7-4
    FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo
    2007 FORD EXPLORER SPORT TRAC
    Bulletin Number: 05235
    NO START WITH INSTRUMENT CLUSTER INOPERATIVE. *TT
    Bulletin Number: 052515
    MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P202 - 4.6L 3V. *TT
    Bulletin Number: 061713
    CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE. *KB
    Bulletin Number: 061912
    DIAGNOSTIC TROUBLE CODES (DTC) P0340, P0344, P0345, P0349. ARE FOUND. *KB
    Bulletin Number: 062414
    LOWER STEERING COLUMN SHAFT POP/CLUNK NOISE. *KB
    Bulletin Number: 0645
    NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS. *TT
    Bulletin Number: 0669
    ANTI-LOCK BRAKE SYSTEM / TRACTION CONTROL / ROLL STABILITY CONTROL INDICATOR (ABS / TC / RSC) WARNING LAMP ON WITH DTC C1440. *TT
    Bulletin Number: 0728
    OVERHEAT INDICATION AND SHIFT QUALITY IMPROVEMENTS - CALIBRATION UPDATE RELEASE - 4.6L 3V WITH 6R60 TRANSMISSION EQUIPPED VEHICLES ONLY. *KB
    Bulletin Number: 0773
    FRONT SEAT MANUAL LUMBAR INOPERATIVE. *KB
    Bulletin Number: 0782
    THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C. *KB
    Bulletin Number: 08-2-8
    IMPROVED BRAKE PEDAL FEEL AND FIRMNESS. *NJ
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44429
    FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC.
    Bulletin Number: DOR-S3J9G-11
    This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
    Bulletin Number: SI-20005
    FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. WHEN COMPARED TO OTHER TRANSMISSIONS, SOME OF THE SHIFT CHARACTERISTICS ARE DIFFERENT THAN PREVIOUS MODELS DUE TO THE 100% S
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-08-18-2
    FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *
    Bulletin Number: TSB-08-19-3
    FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE
    Bulletin Number: TSB-08-9-5
    FORD/MERCURY: 4.0L/4.6L HARD START/ROUGH RUNNING; AFTER LONG HOT SOAK/DIP IN RPM WHEN COMING TO A STOP; BUILT ON OR BEFORE 4/2/08. MAY EXHIBIT A DIP IN RPM BELOW NORMAL IDLE LEVEL OF 600 RPM ON DECELERATION. *PE
    Bulletin Number: TSB-12-7-4
    FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo
    2007 FORD F-150
    Bulletin Number: 061916
    SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION. *KB
    Bulletin Number: 07109
    VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS. *KB
    Bulletin Number: 0719
    EMISSION RECALL. SOFTWARE COULD CAUSE THE CATALYST MONITOR TO STOP FUNCTIONING WHEN CHANGING FUELS. *KB
    Bulletin Number: 07212
    SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
    Bulletin Number: 07213
    HIGH PRESSURE POWER STEERING LINE SEEPAGE-COLD CLIMATES ONLY (EXCLUDING HERITAGE F-150). *NJ
    Bulletin Number: 0765
    REAR AXLE TUBE FRACTURE AT CENTER CARRIER. *KB
    Bulletin Number: 08-14-18
    INTERMITTENT VEHICLE VIBRATION--PARKING BRAKE DISENGAGEMENT CONCERNS. *NJ
    Bulletin Number: 08-2-9
    ERRATIC FUEL GAUGE OPERATION - MIL ON --DTCS P040/P0463 OR INSTRUMENT CLUSTER MODULE DTC B1201--VEHICLES BUILT BEFORE 12/3/2007. *NJ
    Bulletin Number: 19785
    ERRATIC FUEL GAUGE OPERATION MIL/DTC P0460/1/2/3 AND/OR INSTRUMENT CLUSTER DTC B1201 OR B1204 *NJ UPDATED 10/04/07. *NJ
    Bulletin Number: 20228
    1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: CSP-092408CS-01
    FORD TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN THE CASE OF THE ROUSHCHARGER FOR THE F-150, THE TRUCKS CALIBRATION ENHANCEMENTS HAS BEEN DEVELOPED TO BETTER ACCOMMODATE REGIONAL VARIATIONS IN PREMIUM FUEL QUALI
    Bulletin Number: CSP-092908CS-01
    ROUSH/FORD: VEHICLES MANUFACTURED BY ROUSH WITH AN INTERCOOLED ROUSH CHARGER HAVE AN OPPORTUNITY FOR AN UPGRADE TO AN ENHANCED PCM CALIBRATION. NOT ALL F150 ROUSHCHARGED VEHICLES WILL BE AFFECTED BY THESE VARIATIONS. *PE UPDATED 1
    Bulletin Number: SI-20008
    FORD: WATER LEAKS, WIND NOISE AND/OR NOISE ON OPENING/CLOSING THE MOON ROOF/ROOF OPENING PANEL. THE 2004-07 WSM MANUAL PROVIDES TWO SEPARATE PROCEDURES FOR MOON ROOF HEIGHT A HORIZONTAL ADJUSTMENTS. HEIGHT AND HORIZONTAL PROCEDURES NEED TO
    Bulletin Number: SI-20022
    FORD: SOME 2006-2008 F-150 LARIAT, XLT, AND FX4 VEHICLES (EXCLUDING HARLEY DAVIDSON AND XL) MAY EXHIBIT A WHISTLE NOISE FROM THE GRILLE AREA WHEN TRAVELING AT HIGHWAY SPEEDS OF 65MPH AND GREATER. THIS MAY BE THE RESULT OF A POSSIBLE GAP B
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46542
    When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The update
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-10-18-1
    FORD: SOME EXPEDITION, F-150, AND NAVIGATOR MODELS MAY EXPERIENCE A DELAYED FORWARD OR REVERSE TRANSMISSION ENGAGEMENT. USUALLY HAPPENS ON COLD START IN COLD CLIMATES. *RM
    Bulletin Number: TSB-12-8-1
    FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD
    Bulletin Number: TSB-14-0114
    LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
    Bulletin Number: TSB16-0108
    SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo
    2007 FORD F-250
    Bulletin Number: 06007
    BRAKE LINE MODIFICATION NEEDED DUE TO FRONT WHEELS COMING INTO CONTACT WITH THE BRAKE LINES. *KB
    Bulletin Number: 06129
    FRONT WHEEL BEARINGS - NOISE. *TT UPDATED ON 02-27-07. *KB
    Bulletin Number: 0643
    CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ
    Bulletin Number: 0705
    REAR WHEEL BEARING LUBRICATION UPGRADE PRIOR TO SALE. *KB
    Bulletin Number: 071111
    VEHICLES EQUIPPED WITH A 5.4L 3V OR 6.8L 3V ENGINE BUILT ON OR BEFORE 09/08/06 MAY EXHIBIT AN EXHAUST SYSTEM NOISE OFTEN DESCRIBED AS A SNAP/POP/TICK/PING NOISE. *NJ
    Bulletin Number: 07512
    SLOW FUEL FILL. *KB
    Bulletin Number: 08-4-12
    SLOW FUEL FILL--MIL ON WITH DTC P0191. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: TSB-11-4-3
    FORD: 2005-2011 F250/F350. THE FUEL FILL NOZZLE MAY AUTOMATICALLY SHUT OFF TOO EARLY. *RM
    2007 FORD F-250 SD
    Bulletin Number: 06177
    ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
    Bulletin Number: 062401
    6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0643
    CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07112
    STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 07515
    6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 0769
    BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
    Bulletin Number: 0772
    REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
    Bulletin Number: 0798
    ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19521
    LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
    Bulletin Number: 19529
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19537
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19614
    AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19772
    POWER STEERING PUMP PULLEY ALIGNMENT. *KB
    Bulletin Number: 19989
    2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: 20052
    1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ
    Bulletin Number: 20228
    1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
    Bulletin Number: 20232
    2005-08 F250-550 SUPER DUTY MANUAL TRANSMISSION - CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: DOR-B8H4Z-11
    This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
    Bulletin Number: LP-09L02
    FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES HAVE EXPERIENCED SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS AND OSCILLATIONS AFTER TRAVELING OVER A BUMP OR DIP IN THE ROAD. MODELS 2006 F-250/350 SU
    Bulletin Number: SSM 46345
    SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW
    Bulletin Number: SSM 47979
    Some 2005-2019 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now
    Bulletin Number: TSB-08-18-6
    FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    Bulletin Number: TSB-09-20-12
    FORD: SOME SUPER DUTY TRUCKS EQUIPPED WITH A 5.4L 3V OR 6.8L 3V ENGINE MAY EXPERIENCE PREMATURE AUTOMATIC SHUT OFF OF THE FUEL FILL NOZZLE. *PE
    Bulletin Number: TSB-14-0114
    LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
    2007 FORD F-350
    Bulletin Number: 06007
    BRAKE LINE MODIFICATION NEEDED DUE TO FRONT WHEELS COMING INTO CONTACT WITH THE BRAKE LINES. *KB
    Bulletin Number: 06129
    FRONT WHEEL BEARINGS - NOISE. *TT UPDATED ON 02-27-07. *KB
    Bulletin Number: 0643
    CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ
    Bulletin Number: 0705
    REAR WHEEL BEARING LUBRICATION UPGRADE PRIOR TO SALE. *KB
    Bulletin Number: 071111
    VEHICLES EQUIPPED WITH A 5.4L 3V OR 6.8L 3V ENGINE BUILT ON OR BEFORE 09/08/06 MAY EXHIBIT AN EXHAUST SYSTEM NOISE OFTEN DESCRIBED AS A SNAP/POP/TICK/PING NOISE. *NJ
    Bulletin Number: 07312
    WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ
    Bulletin Number: 07512
    SLOW FUEL FILL. *KB
    Bulletin Number: 08-4-12
    SLOW FUEL FILL--MIL ON WITH DTC P0191. *NJ
    Bulletin Number: 19529
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: TSB-08-18-6
    FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
    2007 FORD F-350 SD
    Bulletin Number: 06177
    ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
    Bulletin Number: 062401
    6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0643
    CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07112
    STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 07515
    6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 0769
    BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
    Bulletin Number: 0772
    REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
    Bulletin Number: 0798
    ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19521
    LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
    Bulletin Number: 19537
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19614
    AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19772
    POWER STEERING PUMP PULLEY ALIGNMENT. *KB
    Bulletin Number: 19989
    2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: 20052
    1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ
    Bulletin Number: 20228
    1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
    Bulletin Number: 20232
    2005-08 F250-550 SUPER DUTY MANUAL TRANSMISSION - CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: DOR-B8H4Z-11
    This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
    Bulletin Number: LP-09L02
    FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES HAVE EXPERIENCED SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS AND OSCILLATIONS AFTER TRAVELING OVER A BUMP OR DIP IN THE ROAD. MODELS 2006 F-250/350 SU
    Bulletin Number: SSM 46345
    SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW
    Bulletin Number: SSM 47979
    Some 2005-2019 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now
    Bulletin Number: TSB-08-18-6
    FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    Bulletin Number: TSB-09-20-12
    FORD: SOME SUPER DUTY TRUCKS EQUIPPED WITH A 5.4L 3V OR 6.8L 3V ENGINE MAY EXPERIENCE PREMATURE AUTOMATIC SHUT OFF OF THE FUEL FILL NOZZLE. *PE
    Bulletin Number: TSB-11-4-3
    FORD: 2005-2011 F250/F350. THE FUEL FILL NOZZLE MAY AUTOMATICALLY SHUT OFF TOO EARLY. *RM
    Bulletin Number: TSB-14-0114
    LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
    2007 FORD F-450 SD
    Bulletin Number: 06151
    STEERING WHEEL OSCILLATION. *KB
    Bulletin Number: 06171
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263. *KB
    Bulletin Number: 06176
    HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L ENGINES. *KB
    Bulletin Number: 06177
    ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
    Bulletin Number: 06229
    6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
    Bulletin Number: 06239
    HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP. *KB
    Bulletin Number: 062401
    6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0643
    CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07112
    STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
    Bulletin Number: 0714
    LACK OF COOLING FAN OPERATION. *KB
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 0727
    6.0L - REDUCED ENGINE PERFORMANCE - HIGH ALTITUDE. *KB
    Bulletin Number: 07312
    WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ
    Bulletin Number: 07515
    6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 0769
    BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
    Bulletin Number: 0772
    REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
    Bulletin Number: 0798
    ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19244
    RUNS ROUGH OR MISFIRE DUE TO A STUCK VALVE. *KB
    Bulletin Number: 19247
    OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
    Bulletin Number: 19375
    WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
    Bulletin Number: 19521
    LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
    Bulletin Number: 19529
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19537
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19614
    AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19772
    POWER STEERING PUMP PULLEY ALIGNMENT. *KB
    Bulletin Number: 19989
    2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: 20052
    1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ
    Bulletin Number: 20232
    2005-08 F250-550 SUPER DUTY MANUAL TRANSMISSION - CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: SSM 46345
    SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW
    Bulletin Number: SSM 47979
    Some 2005-2019 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now
    Bulletin Number: TSB-08-18-6
    FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    2007 FORD F-53
    Bulletin Number: 0745
    CERTAIN 2007 MODEL YEAR F-53 MOTORHOME CHASSIS BATTERY/CHARGING LIGHT OVERLAY HARNESS INSTALLATION. *NJ
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: SB-20937
    FORD: MULTIPLE VEHICLES WITH A TORQ SHIFT TRANSMISSION INTERMITTENT CLUNK WHEN SHIFTING BETWEEN DRIVE, REVERSE AND PARK AND/OR DURING 2-3 UPSHIFT. MODELS F SUPER DUTY; E SERIES; EXCURSION; F53 MOTORHOME CHASSIS AND LOW CAB FORWARD.
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46542
    When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The update
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-10-12-11
    FORD: SOME MOTORHOME CHASSIS VEHICLES EQUIPPED WITH A 6.8L ENGINE MAY EXHIBIT HESITATION, LOSS OF RPM AND/OR LOW IDLE RPM DRIVEABILITY CONCERNS. REPROGRAM THE POWERTRAIN CONTROL MODULE (PCM) TO THE LATEST CALIBRATION USING IDS RELEASE 67.
    Bulletin Number: TSB-12-7-4
    FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
    2007 FORD F-550 SD
    Bulletin Number: 06171
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263. *KB
    Bulletin Number: 06176
    HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L ENGINES. *KB
    Bulletin Number: 06177
    ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
    Bulletin Number: 06229
    6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
    Bulletin Number: 06239
    HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP. *KB
    Bulletin Number: 062401
    6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0643
    CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07112
    STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
    Bulletin Number: 0714
    LACK OF COOLING FAN OPERATION. *KB
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 0727
    6.0L - REDUCED ENGINE PERFORMANCE - HIGH ALTITUDE. *KB
    Bulletin Number: 07312
    WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ
    Bulletin Number: 07515
    6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 0769
    BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
    Bulletin Number: 0772
    REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
    Bulletin Number: 0798
    ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19244
    RUNS ROUGH OR MISFIRE DUE TO A STUCK VALVE. *KB
    Bulletin Number: 19247
    OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
    Bulletin Number: 19375
    WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
    Bulletin Number: 19521
    LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
    Bulletin Number: 19529
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19537
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19614
    AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19772
    POWER STEERING PUMP PULLEY ALIGNMENT. *KB
    Bulletin Number: 19989
    2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: 20052
    1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ
    Bulletin Number: 20232
    2005-08 F250-550 SUPER DUTY MANUAL TRANSMISSION - CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: SSM 46345
    SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW
    Bulletin Number: SSM 47979
    Some 2005-2019 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    2007 FORD F-650 SD
    Bulletin Number: 06151
    STEERING WHEEL OSCILLATION. *KB
    Bulletin Number: 06163
    NO START, NO ECM/TCM COMMUNICATIONS AND/OR FLASHING AUTOMATIC TRANSMISSION INDICATOR. *KB
    Bulletin Number: 06169
    RIGHT FUEL TANK EMPTY - FUEL DOES NOT TRANSFER FROM LEFT TANK. *KB
    Bulletin Number: 06171
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263. *KB
    Bulletin Number: 06176
    HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L ENGINES. *KB
    Bulletin Number: 06177
    ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
    Bulletin Number: 061910
    CHECK ENGINE LIGHT ON, AND/OR STOP ENGINE LIGHT ON. CUMMINS ENGINES ONLY. *KB
    Bulletin Number: 06229
    6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
    Bulletin Number: 06237
    WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
    Bulletin Number: 06239
    HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP. *KB
    Bulletin Number: 062401
    6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 06257
    WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07112
    STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
    Bulletin Number: 0714
    LACK OF COOLING FAN OPERATION. *KB
    Bulletin Number: 0715
    VEHICLE DIAGNOSTICS AND PROGRAMMING USING IDS-6.0L ENGINE AND LOW CAB FORWARD WITH 4.5L ENGINE. *KB
    Bulletin Number: 07153
    SOME 2005-2007 F-650 AND F-750 VEHICLES EQUIPPED W/ A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *NJ
    Bulletin Number: 0719
    CHECK ENGINE AND/OR STOP ENGINE LIGHT ON - CUMMINS ENGINE ONLY. *KB
    Bulletin Number: 07199
    SOME 2004-2008 F-SUPER DUTY 650-750 VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT A CONDITION WHERE THE AIR SUSPENSION SPRINGS ARE NOT RE-INFLATING. *NJ
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 0727
    6.0L - REDUCED ENGINE PERFORMANCE - HIGH ALTITUDE. *KB
    Bulletin Number: 07515
    6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 0769
    BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
    Bulletin Number: 0772
    REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
    Bulletin Number: 0792
    DUAL FUEL TANK. ONE EMPTY FUEL DOES NOT TRANSFER. *KB UPDATED 2/6/08. *NJ
    Bulletin Number: 0798
    ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19244
    RUNS ROUGH OR MISFIRE DUE TO A STUCK VALVE. *KB
    Bulletin Number: 19247
    OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
    Bulletin Number: 19375
    WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
    Bulletin Number: 19521
    LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
    Bulletin Number: 19527
    HEADLIGHT ADJUSTMENT NEEDED. *KB
    Bulletin Number: 19529
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19532
    TURN SIGNALS FLASHING RAPIDLY AFTER MODIFICATION. *KB
    Bulletin Number: 19537
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19614
    AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19772
    POWER STEERING PUMP PULLEY ALIGNMENT. *KB
    Bulletin Number: 19989
    2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: SSM 46345
    SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    Bulletin Number: TSB-09-7-5
    FORD TRUCK: SOME VEHICLES MAY EXHIBIT A LOOSE SET BACK. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. *PE
    2007 FORD F-750 SD
    Bulletin Number: 06151
    STEERING WHEEL OSCILLATION. *KB
    Bulletin Number: 06163
    NO START, NO ECM/TCM COMMUNICATIONS AND/OR FLASHING AUTOMATIC TRANSMISSION INDICATOR. *KB
    Bulletin Number: 06169
    RIGHT FUEL TANK EMPTY - FUEL DOES NOT TRANSFER FROM LEFT TANK. *KB
    Bulletin Number: 06171
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263. *KB
    Bulletin Number: 06176
    HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L ENGINES. *KB
    Bulletin Number: 06177
    ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
    Bulletin Number: 061910
    CHECK ENGINE LIGHT ON, AND/OR STOP ENGINE LIGHT ON. CUMMINS ENGINES ONLY. *KB
    Bulletin Number: 06229
    6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
    Bulletin Number: 06237
    WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
    Bulletin Number: 06239
    HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP. *KB
    Bulletin Number: 062401
    6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 06257
    WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
    Bulletin Number: 071110
    BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
    Bulletin Number: 07112
    STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
    Bulletin Number: 0714
    LACK OF COOLING FAN OPERATION. *KB
    Bulletin Number: 0715
    VEHICLE DIAGNOSTICS AND PROGRAMMING USING IDS-6.0L ENGINE AND LOW CAB FORWARD WITH 4.5L ENGINE. *KB
    Bulletin Number: 07153
    SOME 2005-2007 F-650 AND F-750 VEHICLES EQUIPPED W/ A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *NJ
    Bulletin Number: 0719
    CHECK ENGINE AND/OR STOP ENGINE LIGHT ON - CUMMINS ENGINE ONLY. *KB
    Bulletin Number: 07199
    SOME 2004-2008 F-SUPER DUTY 650-750 VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT A CONDITION WHERE THE AIR SUSPENSION SPRINGS ARE NOT RE-INFLATING. *NJ
    Bulletin Number: 07219
    6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
    Bulletin Number: 0727
    6.0L - REDUCED ENGINE PERFORMANCE - HIGH ALTITUDE. *KB
    Bulletin Number: 07515
    6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
    Bulletin Number: 0754
    COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
    Bulletin Number: 0769
    BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
    Bulletin Number: 0772
    REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
    Bulletin Number: 0792
    DUAL FUEL TANK. ONE EMPTY FUEL DOES NOT TRANSFER. *KB UPDATED 2/6/08. *NJ
    Bulletin Number: 0798
    ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
    Bulletin Number: 08-2-11
    6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
    Bulletin Number: 19244
    RUNS ROUGH OR MISFIRE DUE TO A STUCK VALVE. *KB
    Bulletin Number: 19247
    OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
    Bulletin Number: 19375
    WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
    Bulletin Number: 19521
    LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
    Bulletin Number: 19527
    HEADLIGHT ADJUSTMENT NEEDED. *KB
    Bulletin Number: 19529
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19532
    TURN SIGNALS FLASHING RAPIDLY AFTER MODIFICATION. *KB
    Bulletin Number: 19537
    MISFIRE AND DTC P0300. *KB
    Bulletin Number: 19614
    AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
    Bulletin Number: 19621
    LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19728
    LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
    Bulletin Number: 19772
    POWER STEERING PUMP PULLEY ALIGNMENT. *KB
    Bulletin Number: 19989
    2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44404
    FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY,
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    Bulletin Number: SSM 46345
    SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW
    Bulletin Number: TSB-08-9-9
    FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
    Bulletin Number: TSB-09-7-5
    FORD TRUCK: SOME VEHICLES MAY EXHIBIT A LOOSE SET BACK. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. *PE
    2007 FORD FIVE HUNDRED
    Bulletin Number: 06172
    FUEL GAUGE ERRATIC/INACCURATE AND/OR MIL ON WITH DTC P0463, B1202, B2627, B2879, AND/OR P2068. *KB
    Bulletin Number: 0710
    FORDMERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED
    Bulletin Number: 0718
    TRANSMISSION SHIFTER BINDING / HIGH EFFORT BEZEL REPLACEMENT. *KB
    Bulletin Number: 0759
    REAR BRAKE DRAG, NOISE, DUST, AND/OR PREMATURE PAD WEAR. *KB
    Bulletin Number: 08-4-11
    TRACTION CONTROL LAMP ON--NO DTC'S PRESENT, OR DTC P1889 IN DIFFERENTIAL ELECTRONIC MODULE (DEM). *NJ
    Bulletin Number: 19722
    MIL WITH DTC P0106 AND/OR P0109. *KB
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    2007 FORD FOCUS
    Bulletin Number: 06166
    POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB
    Bulletin Number: 06181
    MISFIRE DTC'S P0316, P0300, P0301, P0302, P0303, AND P0304. *KB
    Bulletin Number: 06185
    INCREASED BRAKE PEDAL EFFORTS REQUIRED ON INITIAL STOPPING AFTER COLD START AT HIGH ALTITUDE. *KB
    Bulletin Number: 07113
    POWER STEERING IS LEAKING AND MAKING NOISE. *KB
    Bulletin Number: 0781
    FUEL FILL SLOW EARLY SHUT OFF. *KB
    Bulletin Number: 19188
    ERRATIC FUEL GAUGE AND/OR DTC P0463. *TT
    Bulletin Number: 19355
    DRIVEABILITY CONCERNS AND/OR DTCP0340 - INSPECT CRANKSHAFT PULLEY. *KB
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 19871
    2006-2007 FOCUS- WIRING - 14401 HARNESS CHAFE CONDITION. *NJ
    Bulletin Number: 20144
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44649
    FORD: A JOB AID WAS DEVELOPED AND NOW AVAILABLE FOR THE PTU INTERNAL OR EXTERNAL FLUID LEAKAGE FOR ALL WHEEL DRIVE VEHICLES. *PE
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 47009
    The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a
    Bulletin Number: TB-21399
    FORD: PREMATURE FRONT/REAR TIRE WEAR AND/OR VEHICLE DRIFT ON WET OR SNOW COVERED ROADS. IF PERFORMING AN ALIGNMENT, RECORD ALL ALIGN-MENT ANGLES PRIOR TO ANY ADJUSTMENTS, AND ENTER IN WARRANTY CLAIM IF APPLICABLE. *PE
    Bulletin Number: TSB-0819-9
    FORD: SOME VEHICLES BUILT ON OR AFTER 10/3/05 MAY EXPERIENCE A CUSTOMER CONCERN OF THE POWER STEERING (P/S) SYSTEM LEAKING AND/OR SYSTEM NOISY. *PE
    2007 FORD FREESTAR
    Bulletin Number: 06218
    ADVANCED TRACTION CONTROL SYSTEM - DURATION ACTIVATION. *KB
    Bulletin Number: 071011
    ADVANCED TRACTION CONTROL SYSTEM - SHORT DURATION ACTIVATION. *KB
    Bulletin Number: 0712
    POWER STEERING HOSE LEAK NEAR COOLER EXTREME COLD CLIMATE AREAS ONLY -4 DEGREES AND COOLER. *KB
    Bulletin Number: 07141
    DAMAGED SPARK PLUG ELECTRODE/MIL DTC P030X, ROUGH IDLE, ENGINE KNOCK/PING ON ACCELERATION. *NJ
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: TSB-14-0166
    FORD/MERCURY: SAFETY RECALL REGARDING SHEET METAL SUPPORT FOR FOLDING 3RD ROW SEAT LATCH STRIKERS CAN EXPERIENCE CORROSION AND WILL COMPROMISE MOUNTING POINT CAUSING SEAT TO MOVE. MODEL 2004-07 FREESTAR, MONTEREY. *PE
    2007 FORD FREESTYLE
    Bulletin Number: 06154
    PREMATURE SHOULDER (TOE) WEAR ON INSIDE EDGE OF THE FRONT TIRES. *KB
    Bulletin Number: 06172
    FUEL GAUGE ERRATIC/INACCURATE AND/OR MIL ON WITH DTC P0463, B1202, B2627, B2879, AND/OR P2068. *KB
    Bulletin Number: 0710
    FORDMERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED
    Bulletin Number: 0718
    TRANSMISSION SHIFTER BINDING / HIGH EFFORT BEZEL REPLACEMENT. *KB
    Bulletin Number: 0759
    REAR BRAKE DRAG, NOISE, DUST, AND/OR PREMATURE PAD WEAR. *KB
    Bulletin Number: 19722
    MIL WITH DTC P0106 AND/OR P0109. *KB
    Bulletin Number: CSP-12N03
    FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    2007 FORD F SERIES
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: TB-08-258
    JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE
    2007 FORD FUSION
    Bulletin Number: 06166
    POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB
    Bulletin Number: 0629
    CERTAIN 2007 VEHICLES BUILT BETWEEN JULY 1, 2006 - SEPTEMBER 2, 2006 ARE NOT INCLUDED IN THE OASIS. VEHICLES AFFECTED HAVE OWNER GUIDES WITH POWER DISTRIBUTION BOX FUSING INFORMATION THAT DOES NOT MATCH THE VEHICLE. *KB
    Bulletin Number: 0713
    POWER STEERING FLUID LEAKS FROM STEERING RACK AND PUMP ATTACHMENT JOINTS. *KB UPDATED 2/27/08. *NJ
    Bulletin Number: 0723
    VARIOUS DRIVEABILITY/TRANSMISSION SYMPTOMS - PCM/TCM CALIBRATION UPDATES 3.0L - AISIN F21 AUTO TRANS. *KB
    Bulletin Number: 072315
    MIL ON--DTC P2100 AND P2110 IN MEMORY - 3.0L ENGINE. *NJ
    Bulletin Number: 0773
    FRONT SEAT MANUAL LUMBAR INOPERATIVE. *KB
    Bulletin Number: 17B23
    Certain 2006-2008 Model Year Fusion and Milan, 2006 Zephyr, 2007-2008 MKZ and 2007-2008 Edge, MKX and Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 17B23-S1
    Certain 2006-2008 Model Year Fusion and Milan, 2006 Zephyr, 2007-2008 MKZ and 2007-2008 Edge, MKX and Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 19355
    DRIVEABILITY CONCERNS AND/OR DTCP0340 - INSPECT CRANKSHAFT PULLEY. *KB
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44649
    FORD: A JOB AID WAS DEVELOPED AND NOW AVAILABLE FOR THE PTU INTERNAL OR EXTERNAL FLUID LEAKAGE FOR ALL WHEEL DRIVE VEHICLES. *PE
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: TSB-12-8-1
    FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD
    Bulletin Number: TSB-13-4-17
    FORD/LINCOLN/MERCURY: SOME VEHICLES, WITH DIAGNOSTIC CODES (DTCS) P0351, P0352, P0353, P0354, P0355, MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP IN THE POWERTRAIN CONTROL MODULE (PCM) AND ONE OR MORE COIL ON PLUG(S) DAMAGE. MODELS 2006-08
    2007 FORD GRAND MARQUIS
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: RP-13-R-01
    FORD: SWING LINK JOINTS ON LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION, AND COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, ON SOME VEHICLES, CAUSES STEERING COLUMN TO SEPARATE, LEADING TO STEERING CONTROL LOSS. MODEL 2005
    Bulletin Number: SI-19982
    FORD: ENGINE COOLING FAN CONTROL RELAY PART AVAILABILITY. *PE
    2007 FORD LCF 450 SERIES
    Bulletin Number: 0640
    CUSTOMER SATISFACTION PROGRAM. ENGINE CRANKCASE VENTILLATION SYSTEM UPGRADE. FORD. CERTAIN 2006 AND 2007 LOW CAB FORWARD VEHICLES. *KB
    Bulletin Number: 0771
    HARD START/LONG CRANK OR NO START - LOW ICP. *KB
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    2007 FORD LCF 550 SERIES
    Bulletin Number: 0640
    CUSTOMER SATISFACTION PROGRAM. ENGINE CRANKCASE VENTILLATION SYSTEM UPGRADE. FORD. CERTAIN 2006 AND 2007 LOW CAB FORWARD VEHICLES. *KB
    Bulletin Number: 0771
    HARD START/LONG CRANK OR NO START - LOW ICP. *KB
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-44534
    FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *P
    2007 FORD MUSTANG
    Bulletin Number: 01011901
    REAR SHOCK SERVICE PROGRAM. *KB
    Bulletin Number: 04032007
    REFLASHING THE POWERTRAIN CONTROL MODULE (PCM). *KB
    Bulletin Number: 07103
    AIR BAG WARNING LAMP ON - DTC 2295 IN RESTRAINTS CONTROL MODULE AND LAMP FLASH CODE 22. *KB
    Bulletin Number: 14B04
    FORD: 2005-2006 FORD GT, 2005-2008 MUSTANG, AND 2004-2005 RANGER VEHICLES OPERATED IN FLORIDA, HAWAII, PUERTO RICO, OR THE U.S VIRGIN ISLANDS ARE IN NEED OF AN AIRBAG INFLATOR REPLACEMENT. 06/11/15 *TA.
    Bulletin Number: 14B09
    FORD: SOME 2005-2006 FORD GT AND 2005-2008 MUSTANG VEHICLES WILL BE RECEIVING DRIVER AIRBAG INFLATOR REPLACEMENTS. *TA
    Bulletin Number: 19296
    ABS WARNING LAMP ON. GROUND G101. *KB
    Bulletin Number: 20523
    FORD: AIRBAG LIGHT-PRETENSIONER PIGTAIL KIT AVAILABLE. VEHICLES MAY EXHIBIT AIRBAG LIGHT WITH B2292 HARD FAULT CODE POINTING TOWARD SEAT BELT PRETENSIONER. REPLACE BODY WIRING HARNESS CONNECTOR. *PE
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: ASI-08-26-07
    FORD; SOME VEHICLES MAY EXHIBIT A DIFFICULT TO DIAGNOSE WATER LEAK IN FRONT FLOOR AREA. THIS MAY BE CAUSED BY LOOSE GROMMETS AND/OR SEALER SKIPS AROUND COWL AREA, LOOSE A PILLAR WINDOW WEATHERSTRIP RETAINER. *PE
    Bulletin Number: ASI-44352
    FORD: DUE TO VEHICLES, WITH CARBON FIBER CLUTCHES, A CHATTER OR MOAN/GROAN NOISE IS HEARD WHILE MAKING SHARP TURNS, AT LOW SPEED AND IS CHARACTERISTIC OF HEAVY DUTY/RACING TYPE LIMITED SLIP DIFFERENTIAL. MODEL 2007-2014 MUSTANG GT500, GT,
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-07-14-6
    FORD: IN SOME VEHICLES THERE MAY EXHIBIT A DIFFICULT DIAGNOSE OF A WATER LEAK IN THE FRONT FLOOR AREA. *PE
    Bulletin Number: TSB-08-26-7
    FORD: VEHICLE MAY EXHIBIT A DIFFICULT TO DIAGNOSE WATER LEAK IN THE FRONT FLOOR AREA. MAY BE CAUSED BY LOOSE GROMMETS AND/OR SEALER SKIPS AROUND THE COWL AREA, LOOSE A-PILLAR WINDOW WEATHERSTRIP RETAINER. *PE
    Bulletin Number: TSB-08-9-2
    FORD: UN-COMMANDED PERIMETER LIGHTING. VEHICLES MAY EXHIBIT UN-COMMANDED PERIMETER LIGHTING FEATURE (HEAD, PARK AND SIDE MARKER LAMPS) DUE TO WATER INDUCED SHORT TO GROUND IN THE DOOR DISARM SWITCH. *PE
    Bulletin Number: TSB-08-9-6
    FORD: 4.6L WITH TR3650 MANUAL TRANSMISSION; CLASH OR RASPY FEEL; SHIFTING INTO 2ND AND/OR 3RD GEAR. CONDITION MAY BE MORE PRONOUNCED WHEN THE TRANSMISSION IS COLDER THAN 40 DEGREES F (5 DEGREES C). *PE
    Bulletin Number: TSB-09-19-11
    FORD: SOME VEHICLES (SHELBY GT 500) MAY EXHIBIT THE FOLLOWING CLUTCH/TRANSMISSION SYMPTOMS: HARD TO DISENGAGE OR ENGAGE 1ST AND REVERSE, HARD TO SHIFT ANY GEAR, VEHICLE CREEPS WITH TRANSMISSION IN GEAR AND CLUTCH PEDAL FULLY DEPRESSED WITH
    Bulletin Number: TSB-10-23-8
    FORD: 2007-2009 MUSTANG. A WIRING HARNESS CONNECTION MAY BE CAUSING THE AIR BAG LIGHT TO ILLUMINATE IN VEHICLES WITH SIDE AIR BAGS. *RM
    Bulletin Number: TSB-12-7-4
    FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo
    2007 FORD RANGER
    Bulletin Number: 06166
    POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB
    Bulletin Number: 061711
    MIL ON - DTC P0401 MIS-ROUTED VACUUM HARNESS. *KB
    Bulletin Number: 08-2-5
    DELAYED AUTOMATIC TRANSMISSION ENGAGEMENT--BUILT ON OR BEFORE 2/14/08. *NJ UPDATED 5/30/08. *NJ
    Bulletin Number: 16B15
    Certain 2007-2008 Model Year Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 16B15-S1
    Certain 2007-2008 Model Year Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 17B23
    Certain 2006-2008 Model Year Fusion and Milan, 2006 Zephyr, 2007-2008 MKZ and 2007-2008 Edge, MKX and Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 17B23-S1
    Certain 2006-2008 Model Year Fusion and Milan, 2006 Zephyr, 2007-2008 MKZ and 2007-2008 Edge, MKX and Ranger Vehicles - Driver Airbag Inflator Replacement
    Bulletin Number: 19355
    DRIVEABILITY CONCERNS AND/OR DTCP0340 - INSPECT CRANKSHAFT PULLEY. *KB
    Bulletin Number: 19523
    FUEL SENDER PART CATALOG CORRECTION. *KB
    Bulletin Number: 19844
    SOME 2007 RANGER - POP, CLUNK, AND/OR CLICK NOISE FROM STEERING. *NJ
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 20144
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 20147
    2007-2008 RANGER - B1342 IN OCCUPANT CLASSIFICATION SENSOR (OCS) SYSTEM MODULE. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 47009
    The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a
    2007 FORD SUPER DUTY
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: SB-09M02
    FORD: CERTAIN VEHICLES WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT; SPECIFIC COMPONENT WARRANTY EXTENSION. AWARENESS COMMUNICATION, DATED 4/20/09. *PE
    Bulletin Number: SB-09M03
    FORD: CERTAIN VEHICLES, E SERIES AND F SUPER DUTY, WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT-6.0L DIESEL ENGINE REPLACEMENT WARRANTY EXTENSION. AWARENESS COMMUNICATION DATED 4/20/09. *PE
    Bulletin Number: SB-20937
    FORD: MULTIPLE VEHICLES WITH A TORQ SHIFT TRANSMISSION INTERMITTENT CLUNK WHEN SHIFTING BETWEEN DRIVE, REVERSE AND PARK AND/OR DURING 2-3 UPSHIFT. MODELS F SUPER DUTY; E SERIES; EXCURSION; F53 MOTORHOME CHASSIS AND LOW CAB FORWARD.
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46542
    When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The update
    Bulletin Number: SSM 47331
    Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam
    Bulletin Number: TSB-08-16-13
    FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE
    Bulletin Number: TSB-08-20-1
    FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
    Bulletin Number: TSB-08-23-8
    FORD: VEHICLES MAY EXHIBIT FUEL IN THE ENGINE COOLANT, DUE TO LEAKS IN THE CYLINDER HEAD FUEL INJECTOR AREA. SYMPTOMS MAY INCLUDE FUEL IN ENGINE COOLANT AND COOLANT EXPULSION FROM THE DEGAS BOTTLE. *PE UPDATED 3/20/09.
    Bulletin Number: TSB-08-26-3
    FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
    2007 FORD TAURUS
    Bulletin Number: 19865
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: 20144
    MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
    Bulletin Number: AS-21769
    FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
    Bulletin Number: SSM 46085
    The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
    Bulletin Number: SSM 46412
    SOME 2007-2016 EDGE/MKX/FLEX/MKT/MKZ/MKS/TAURUS/TAURUS POLICE/EXPLORER/EXPLORER POLICE EQUIPPED WITH ALL WHEEL DRIVE (AWD) AND BUILT ON OR BEFORE 30-JUN-2016 MAY EXHIBIT A TICKING AND/OR KNOCKING NOISE COMING FROM THE DRIVELINE AREA. TO IDE
    Bulletin Number: TSB 19-2026
    Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo

     

    Recalls for 2007 Ford

    2007 FORD CROWN VICTORIA
    NHTSA Campaign ID:STEERING
    Manufacturer:Ford Motor Company
    Manufacture Dates: -
    Potential Units Affected:355000

    Defect Description:

    Ford is recalling certain model year 2005-2011 Ford Crown Victoria (including Crown Victoria Police Interceptors), Mercury Grand Marquis, and Lincoln Town Car vehicles. The affected vehicles are currently registered or were originally sold in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. Severe corrosion can seize the lower intermediate shaft which may cause the upper intermediate shaft to collapse and the steering column lower bearing to separate.

    Consequence:

    If the lower bearing separates, the vehicle may experience a loss of steering, increasing the risk of a crash.

    Action:

    Ford will notify owners and dealers will replace the lower intermediate shaft, free of charge. The upper intermediate shaft and steering column lower bearing will be inspected to identify any damage that may have occurred as a result of lower intermediate shaft corrosion, and repaired or replaced as necessary. If the steering column lower bearing has separated, a retainer clip will be installed. The recall began on October 23, 2013. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S08.
    2007 FORD CROWN VICTORIA
    NHTSA Campaign ID:VISIBILITY:WINDSHIELD
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:08/28/2006 - 08/29/2006
    Potential Units Affected:422

    Defect Description:

    CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD MAY NOT BE PROPERLY SECURED TO THE VEHICLE BODY.

    Consequence:

    IF THE WINDSHIELD IS NOT PROPERLY RETAINED TO THE VEHICLE, WIND NOISE, SQUEAK/RATTLES AND/OR WATER LEAKS MAY OCCUR. ALSO, LOSS OF WINDSHIELD RETENTION MAY REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 22, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD CROWN VICTORIA
    NHTSA Campaign ID:STEERING:RACK AND PINION:PINION SHAFT
    Manufacturer:Ford Motor Company
    Manufacture Dates:03/23/2004 - 08/30/2011
    Potential Units Affected:36888

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2005-2011 Ford Crown Victoria, 2005-2011 Mercury Grand Marquis vehicles manufactured March 23, 2004, to August 30, 2011, and 2005-2011 Lincoln Town Car vehicles manufactured March 8, 2004, to August 30, 2011, and on which the upper intermediate shaft was serviced during the course of safety recall 13V-385. The prior repairs may not have been correctly performed.

    Consequence:

    Improper servicing of the upper intermediate shaft could cause the shaft to separate, which can then result in a loss of steering control, and increasing the risk of a crash.

    Action:

    Ford will notify the owners of vehicles whose repair records reflect that the upper intermediate steering shaft was repaired during the course of the prior recall 13V-385. Dealers will inspect and replace the upper immediate shaft if necessary free of charge. The recall began November 17, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S25.
    2007 FORD CROWN VICTORIA
    NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:03/30/2007 - 04/04/2007
    Potential Units Affected:630

    Defect Description:

    CERTAIN PASSENGER VEHICLES EQUIPPED WITH ANTILOCK BRAKE SYSTEMS (ABS) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THE FRONT AND REAR RIGHT SIDE BRAKE LINES MAY BE REVERSED AT THE ABS HYDRAULIC CONTROL UNIT.

    Consequence:

    THE BRAKES MAY NOT OPERATE AS INTENDED, WHICH COULD RESULT IN A CRASH.

    Action:

    DEALERS WILL INSPECT THE BRAKE LINE CONNECTIONS AND THE HYDRAULIC CONTROL UNIT AND REPOSITION THEM FREE OF CHARGE. THE RECALLBEGAN ON APRIL 27, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY TRANSPORTATION SERVICES
    Manufacture Dates:09/16/2008 - 04/15/2009
    Potential Units Affected:60

    Defect Description:

    MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    MTS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY WORKS
    Manufacture Dates:04/01/2005 - 10/09/2007
    Potential Units Affected:224

    Defect Description:

    MOBILITYWORKS IS RECALLING 224 MY 2007-2008 FORD E150, MY 2006-2008 E250, MY 2004-2007 E350, MY 2006 E450, MY 2005-2007 CHEVROLET 2500, MY 2007 CHEVROLET 1500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY WORKS AT 1-800-769-8267.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCUBUILT, INC.
    Manufacture Dates:10/17/2005 - 10/12/2007
    Potential Units Affected:890

    Defect Description:

    ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    ACCUBUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ACCUBUILT AT 1-800-837-8624.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY TRANSPORTATION SERVICES
    Manufacture Dates:09/16/2008 - 04/15/2009
    Potential Units Affected:60

    Defect Description:

    MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    MTS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM-TRANS
    Manufacture Dates:12/07/2007 - 12/23/2009
    Potential Units Affected:65

    Defect Description:

    COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    COMM-TRANS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM-TRANS AT 1-901-726-9394.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:National Van Builiders, Inc.
    Manufacture Dates:01/01/2006 - 09/12/2014
    Potential Units Affected:45

    Defect Description:

    National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    National Van will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 3, 2014. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon2014.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:08/01/2006 - 08/31/2012
    Potential Units Affected:37

    Defect Description:

    Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

    Consequence:

    If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.

    Action:

    Mobility Works will notify owners and Ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin July 15, 2013. Owners may contact Mobility Works at 1-877-275-4912 and Ricon at 1-818-267-3000.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:CUMMINGS MOBILITY CONVERSION & SUPPLY, I
    Manufacture Dates: -
    Potential Units Affected:42

    Defect Description:

    CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:CUMMINGS MOBILITY CONVERSION & SUPPLY, I
    Manufacture Dates: -
    Potential Units Affected:42

    Defect Description:

    CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN CONVERSIONS OF LEHIGH VALLEY INC.
    Manufacture Dates:04/01/2005 - 09/06/2006
    Potential Units Affected:52

    Defect Description:

    VAN CONVERSIONS IS RECALLING 52 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN CONVERSIONS OF LEHIGH VALLEY INC.
    Manufacture Dates:04/01/2005 - 10/09/2007
    Potential Units Affected:74

    Defect Description:

    VAN CONVERSIONS IS RECALLING 74 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
    2007 FORD E-150
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:09/11/2006 - 11/10/2006
    Potential Units Affected:57199

    Defect Description:

    FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK.

    Consequence:

    FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

    Action:

    DEALERS WILL REPLACE THE FUEL RAIL ASSEMBLY. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Cummings Mobility Conversion & Supply
    Manufacture Dates:01/01/2006 - 10/08/2014
    Potential Units Affected:34

    Defect Description:

    Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:01/01/2006 - 12/31/2014
    Potential Units Affected:667

    Defect Description:

    MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Specialists, Inc.
    Manufacture Dates: -
    Potential Units Affected:56

    Defect Description:

    Mobility Specialists, Inc. (Mobility Specialists) is recalling certain model year 2007-2008 Ford E-150 vans modified by Mobility Specialists and equipped with Braun NCL-2, and NVL-2 wheel chair lifts. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.

    Consequence:

    A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

    Action:

    Mobility Specialists will notify owners and will replace the affected parts, free of charge. The recall began in July 2014. Owners may contact Mobility Specialists customer service at 1-877-777-5438.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM-TRANS
    Manufacture Dates:12/07/2007 - 12/23/2009
    Potential Units Affected:65

    Defect Description:

    COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    COMM-TRANS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM-TRANS AT 1-901-726-9394.
    2007 FORD E-150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCUBUILT, INC.
    Manufacture Dates:10/17/2005 - 10/12/2007
    Potential Units Affected:890

    Defect Description:

    ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    ACCUBUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT OCTOBER 6, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ACCUBUILT AT 1-800-837-8624.
    2007 FORD E150
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:01/01/2006 - 10/09/2014
    Potential Units Affected:834

    Defect Description:

    Mobility Works (WMK Inc.) is recalling certain model year 2006-2014 Ford E150, E250, and E350 vans modified by Mobility Works to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Mobility Works will notify owners, and Ricon will supply supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 10, 2014. Owners may contact Mobility Works customer service at 1-800-769-8267 or Ricon customer service at 1-800-322-2884.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:08/01/2006 - 08/31/2012
    Potential Units Affected:37

    Defect Description:

    Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

    Consequence:

    If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.

    Action:

    Mobility Works will notify owners and Ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin July 15, 2013. Owners may contact Mobility Works at 1-877-275-4912 and Ricon at 1-818-267-3000.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN PRODUCTS MOBILITY & COMMERCIAL
    Manufacture Dates: -
    Potential Units Affected:8

    Defect Description:

    VAN PRODUCTS IS RECALLING 8 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THE LIFT FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    VAN PRODUCTS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:PERSONALIZED VANS AND TRUCKS
    Manufacture Dates:07/08/2006 - 08/16/2006
    Potential Units Affected:2

    Defect Description:

    PERSONALIZED VANS AND TRUCKS IS RECALLING CERTAIN VANS EQUIPPED WITH PLATFORM STYLE WHEELCHAIR LIFTS MANUFACTURED BY RICON CORPORATION. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    PERSONALIZED VANS AND TRUCKS IS WORKING WITH RICON CORPORATION TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON CORPORATION AT 1-818-267-3000.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCESSIBLE VANS & MOBILTIY OF NY, LLC
    Manufacture Dates: -
    Potential Units Affected:1

    Defect Description:

    ACCESSIBLE VANS IS RECALLING 1 VAN EQUIPPED WITH A RICON PLATFORM STYLE WHEELCHAIR LIFT. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    ACCESSIBLE VANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:New England Wheels
    Manufacture Dates:01/01/2006 - 04/20/2015
    Potential Units Affected:2

    Defect Description:

    New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.

    Action:

    New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN CONVERSIONS OF LEHIGH VALLEY INC.
    Manufacture Dates:04/01/2005 - 09/06/2006
    Potential Units Affected:52

    Defect Description:

    VAN CONVERSIONS IS RECALLING 52 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCUBUILT, INC.
    Manufacture Dates:10/17/2005 - 10/12/2007
    Potential Units Affected:890

    Defect Description:

    ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    ACCUBUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT OCTOBER 6, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ACCUBUILT AT 1-800-837-8624.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN CONVERSIONS OF LEHIGH VALLEY INC.
    Manufacture Dates:04/01/2005 - 10/09/2007
    Potential Units Affected:74

    Defect Description:

    VAN CONVERSIONS IS RECALLING 74 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT:AIR CONDITIONER
    Manufacturer:ENG MOBILE SYSTEM, INC
    Manufacture Dates:05/01/2007 - 08/31/2009
    Potential Units Affected:53

    Defect Description:

    E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

    Consequence:

    THIS DEFECT COULD RESULT IN A FIRE.

    Action:

    E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.
    2007 FORD E-250
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:09/11/2006 - 11/10/2006
    Potential Units Affected:57199

    Defect Description:

    FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK.

    Consequence:

    FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

    Action:

    DEALERS WILL REPLACE THE FUEL RAIL ASSEMBLY. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Specialists, Inc.
    Manufacture Dates:04/04/2006 - 08/07/2014
    Potential Units Affected:285

    Defect Description:

    Mobility Specialists, Inc. (Mobility Specialists) is recalling certain model year 2006-2014 Ford E-250, and E-350 vehicles modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Additionally, the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator. Additionally, if the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    Mobility Specialists will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 13, 2015. Owners may contact Mobility Specialists customer service at 1-877-777-5438, or Ricon customer service at 1-800-322-2884.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM-TRANS
    Manufacture Dates:12/07/2007 - 12/23/2009
    Potential Units Affected:65

    Defect Description:

    COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    COMM-TRANS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM-TRANS AT 1-901-726-9394.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCUBUILT, INC.
    Manufacture Dates:10/17/2005 - 10/12/2007
    Potential Units Affected:890

    Defect Description:

    ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    ACCUBUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ACCUBUILT AT 1-800-837-8624.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:QUALITY VAN SALES, INC.
    Manufacture Dates:09/01/2005 - 01/31/2007
    Potential Units Affected:18

    Defect Description:

    QUALITY VAN SALES IS RECALLING 18 MY 2005-2007 FORD E-250, MY 2006 FORD E-350 AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    QUALITY VAN SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VAN SALES AT 1-800-408-8550.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:QUALITY VAN SALES, INC.
    Manufacture Dates:09/01/2005 - 01/31/2007
    Potential Units Affected:18

    Defect Description:

    QUALITY VAN SALES IS RECALLING 18 MY 2005-2007 FORD E-250, MY 2006 FORD E-350, AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    QUALITY VAN SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VAN SALES AT 1-800-408-8550.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY TRANSPORTATION SERVICES
    Manufacture Dates:09/16/2008 - 04/15/2009
    Potential Units Affected:60

    Defect Description:

    MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    MTS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:New England Wheels
    Manufacture Dates:01/01/2006 - 09/30/2014
    Potential Units Affected:278

    Defect Description:

    New England Wheels is recalling certain model year 2006-2014 Ford E-250, and E-350 cargo vans modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    New England Wheels will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on January 5, 2016. Owners may contact New England Wheels customer service at 1-800-866-9247, or Ricon Customer Service at 1-800-322-2884. New England Wheels' number for this recall is 15E-068. Note: These vans and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM-TRANS
    Manufacture Dates:12/07/2007 - 12/23/2009
    Potential Units Affected:65

    Defect Description:

    COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    COMM-TRANS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM-TRANS AT 1-901-726-9394.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Cummings Mobility Conversion & Supply
    Manufacture Dates:01/01/2006 - 10/08/2014
    Potential Units Affected:34

    Defect Description:

    Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:01/01/2006 - 12/31/2014
    Potential Units Affected:667

    Defect Description:

    MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY TRANSPORTATION SERVICES
    Manufacture Dates:09/16/2008 - 04/15/2008
    Potential Units Affected:60

    Defect Description:

    MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    MTS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY WORKS
    Manufacture Dates:04/01/2005 - 10/09/2007
    Potential Units Affected:224

    Defect Description:

    MOBILITYWORKS IS RECALLING 224 MY 2007-2008 FORD E150, MY 2006-2008 E250, MY 2004-2007 E350, MY 2006 E450, MY 2005-2007 CHEVROLET 2500, MY 2007 CHEVROLET 1500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY WORKS AT 1-800-769-8267.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:New England Wheels
    Manufacture Dates:02/01/2006 - 08/31/2014
    Potential Units Affected:286

    Defect Description:

    New England Wheels (New England) is recalling certain model year 2006-2014 E-250, and E-350 vehicles modified by New England to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    New England will notify owners to take vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 17, 2014. Owners may contact New England customer service at 1-800-886-9247 or Ricon customer service at 1-800-322-2884. New England's number for this recall is 14E-041.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:PERSONALIZED VANS AND TRUCKS
    Manufacture Dates:07/08/2006 - 08/16/2006
    Potential Units Affected:2

    Defect Description:

    PERSONALIZED VANS AND TRUCKS IS RECALLING CERTAIN VANS EQUIPPED WITH PLATFORM STYLE WHEELCHAIR LIFTS MANUFACTURED BY RICON CORPORATION. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    PERSONALIZED VANS AND TRUCKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON CORPORATION AT 1-818-267-3000.
    2007 FORD E-250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:National Van Builiders, Inc.
    Manufacture Dates:01/01/2006 - 09/12/2014
    Potential Units Affected:45

    Defect Description:

    National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    National Van will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 3, 2014. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon2014.
    2007 FORD E250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:01/01/2006 - 10/09/2014
    Potential Units Affected:834

    Defect Description:

    Mobility Works (WMK Inc.) is recalling certain model year 2006-2014 Ford E150, E250, and E350 vans modified by Mobility Works to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Mobility Works will notify owners, and Ricon will supply supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 10, 2014. Owners may contact Mobility Works customer service at 1-800-769-8267 or Ricon customer service at 1-800-322-2884.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT:AIR CONDITIONER
    Manufacturer:BRAUN CORPORATION
    Manufacture Dates:04/27/2005 - 07/29/2010
    Potential Units Affected:185

    Defect Description:

    BRAUN IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 PARATRANSIT VANS BUILT ON FORD E-350 CHASSIS FROM APRIL 27, 2005, THROUGH JULY 29, 2010, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS (EM-1) MANUFACTURED FROM JANUARY 1, 2006 THROUGH DECEMBER 2010, CONTAINING A DELPHI PACK-CON III FUSE HOLDER IN AN ALLIED MOTION MOTOR ASSEMBLY; EM-1 UNIT PART NUMBERS 77-62112-XX AND 77-62512-XX, STARTING WITH SERIAL NUMBER KNT90890232 TO SERIAL NUMBER NNE91230058. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

    Consequence:

    IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND MAY BE ACCOMPANIED BY FLAME, SMOKE AND POTENTIAL FIRE.

    Action:

    BRAUN WILL NOTIFY OWNERS AND INSTRUCT THEM TO CONTACT EITHER CARRIER OR A BRAUN DEALER TO OBTAIN THE FREE REMEDY. THE SAFETY RECALL BEGAN ON MARCH 17, 2011. OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR BRAUN AT 1-800-THE-LIFT (1-800-843-5438).
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT:AIR CONDITIONER
    Manufacturer:CUES, INC.
    Manufacture Dates: -
    Potential Units Affected:269

    Defect Description:

    CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

    Consequence:

    THIS DEFECT COULD RESULT IN A FIRE.

    Action:

    CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY TRANSPORTATION SERVICES
    Manufacture Dates:09/16/2008 - 04/15/2009
    Potential Units Affected:60

    Defect Description:

    MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    MTS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM-TRANS
    Manufacture Dates:12/07/2007 - 12/23/2009
    Potential Units Affected:65

    Defect Description:

    COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    COMM-TRANS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM-TRANS AT 1-901-726-9394.
    2007 FORD E-350
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:09/11/2006 - 11/10/2006
    Potential Units Affected:57199

    Defect Description:

    FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK.

    Consequence:

    FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

    Action:

    DEALERS WILL REPLACE THE FUEL RAIL ASSEMBLY. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ELKHART COACH
    Manufacture Dates: -
    Potential Units Affected:41

    Defect Description:

    ELKHART COACH HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN TRANSIT BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    ELKHART COACH IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800-322-2884, EMAILING AT WWW.DMATA@WABTEC.COM.
    2007 FORD E-350
    NHTSA Campaign ID:SUSPENSION:REAR
    Manufacturer:FRONTLINE COMMUNICATIONS
    Manufacture Dates:10/31/2006 - 07/12/2011
    Potential Units Affected:75

    Defect Description:

    FRONTLINE IS RECALLING CERTAIN MODEL YEAR 2006-2011 ELECTRONIC NEWS GATHERING (ENG) VEHICLES BUILT ON A FORD E-350 CHASSIS WITH AN AFTERMARKET REAR ANTI-SWAY BAR AND MANUFACTURED FROM OCTOBER 31, 2006, THROUGH JULY 12, 2011. THESE VEHICLES MAY BE SUSCEPTIBLE TO REAR HYDRAULIC BRAKE LINE DAMAGE. THE REAR ANTI-SWAY BAR FRAME MOUNTING BOLT THREADS MAY COME IN CONTACT WITH THE STEEL HYDRAULIC BRAKE LINE. IF METAL-TO-METAL ABRASION OCCURS, THE BRAKE LINE MAY EVENTUALLY RUPTURE AND CAUSE A LOSS OF HYDRAULIC SERVICE BRAKE PRESSURE.

    Consequence:

    IF A LOSS OF SERVICE BRAKE PRESSURE OCCURS, THE DRIVER MAY NOT BE ABLE TO CONTROL THE VEHICLE, INCREASING THE RISK OF A CRASH

    Action:

    FRONTLINE WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY LOCAL FORD DEALERS AND FRONTLINE AUTHORIZED SERVICE FACILITIES. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON JULY 12, 2011. OWNERS MAY CONTACT FRONTLINE COMMUNICATIONS AT 1-727-573-0400.
    2007 FORD E-350
    NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
    Manufacturer:FRONTLINE COMMUNICATIONS
    Manufacture Dates:10/31/2006 - 07/12/2011
    Potential Units Affected:75

    Defect Description:

    FRONTLINE IS RECALLING CERTAIN MODEL YEAR 2006-2011 ELECTRONIC NEWS GATHERING (ENG) VEHICLES BUILT ON A FORD E-350 CHASSIS WITH AN AFTERMARKET REAR ANTI-SWAY BAR AND MANUFACTURED FROM OCTOBER 31, 2006, THROUGH JULY 12, 2011. THESE VEHICLES MAY BE SUSCEPTIBLE TO REAR HYDRAULIC BRAKE LINE DAMAGE. THE REAR ANTI-SWAY BAR FRAME MOUNTING BOLT THREADS MAY COME IN CONTACT WITH THE STEEL HYDRAULIC BRAKE LINE. IF METAL-TO-METAL ABRASION OCCURS, THE BRAKE LINE MAY EVENTUALLY RUPTURE AND CAUSE A LOSS OF HYDRAULIC SERVICE BRAKE PRESSURE.

    Consequence:

    IF A LOSS OF SERVICE BRAKE PRESSURE OCCURS, THE DRIVER MAY NOT BE ABLE TO CONTROL THE VEHICLE, INCREASING THE RISK OF A CRASH

    Action:

    FRONTLINE WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY LOCAL FORD DEALERS AND FRONTLINE AUTHORIZED SERVICE FACILITIES. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON JULY 12, 2011. OWNERS MAY CONTACT FRONTLINE COMMUNICATIONS AT 1-727-573-0400.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY WORKS
    Manufacture Dates:04/01/2005 - 10/09/2007
    Potential Units Affected:224

    Defect Description:

    MOBILITYWORKS IS RECALLING 224 MY 2007-2008 FORD E150, MY 2006-2008 E250, MY 2004-2007 E350, MY 2006 E450, MY 2005-2007 CHEVROLET 2500, MY 2007 CHEVROLET 1500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY WORKS AT 1-800-769-8267.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCUBUILT, INC.
    Manufacture Dates:10/17/2005 - 10/12/2007
    Potential Units Affected:890

    Defect Description:

    ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    ACCUBUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ACCUBUILT AT 1-800-837-8624.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ELKHART COACH
    Manufacture Dates: -
    Potential Units Affected:200

    Defect Description:

    ELKHART COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN TRANSIT BUSES EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    ELKHART COACH WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. CURRENTLY RICON IS DEVELOPING A SOFTWARE SOLUTION AND IS NOT AVAILABLE. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800- 322-2884, EMAILING AT WWW.DMATA@WABTEC.COM.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:MOBILITY TRANSPORTATION SERVICES
    Manufacture Dates:09/16/2008 - 04/15/2009
    Potential Units Affected:60

    Defect Description:

    MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    MTS IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MTS AT 1-734-453-6452.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ACCUBUILT, INC.
    Manufacture Dates:10/17/2005 - 10/12/2007
    Potential Units Affected:890

    Defect Description:

    ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    ACCUBUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT OCTOBER 6, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ACCUBUILT AT 1-800-837-8624.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM-TRANS
    Manufacture Dates:12/07/2007 - 12/23/2009
    Potential Units Affected:65

    Defect Description:

    COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    COMM-TRANS WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 6, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM-TRANS AT 1-901-726-9394.
    2007 FORD E-350
    NHTSA Campaign ID:SEATS
    Manufacturer:ACCESS OPTIONS, INC
    Manufacture Dates: -
    Potential Units Affected:4

    Defect Description:

    ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

    Consequence:

    THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

    Action:

    THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Elkhart Coach
    Manufacture Dates:01/01/2006 - 05/01/2014
    Potential Units Affected:437

    Defect Description:

    Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Cummings Mobility Conversion & Supply
    Manufacture Dates:01/01/2006 - 10/08/2014
    Potential Units Affected:34

    Defect Description:

    Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT:AIR CONDITIONER
    Manufacturer:ENG MOBILE SYSTEM, INC
    Manufacture Dates:05/01/2007 - 08/31/2009
    Potential Units Affected:53

    Defect Description:

    E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

    Consequence:

    THIS DEFECT COULD RESULT IN A FIRE.

    Action:

    E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN CONVERSIONS OF LEHIGH VALLEY INC.
    Manufacture Dates:04/01/2005 - 10/09/2007
    Potential Units Affected:74

    Defect Description:

    VAN CONVERSIONS IS RECALLING 74 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:VAN CONVERSIONS OF LEHIGH VALLEY INC.
    Manufacture Dates:04/01/2005 - 09/06/2006
    Potential Units Affected:52

    Defect Description:

    VAN CONVERSIONS IS RECALLING 52 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:CUMMINGS MOBILITY CONVERSION & SUPPLY, I
    Manufacture Dates: -
    Potential Units Affected:42

    Defect Description:

    CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:BOULEVARD VAN CITY, LLC
    Manufacture Dates: -
    Potential Units Affected:3

    Defect Description:

    BOULEVARD IS RECALLING 3 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    BOULEVARD IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:A WORK OF ART MFG.
    Manufacture Dates:01/25/2007 - 11/01/2007
    Potential Units Affected:3

    Defect Description:

    A WORK OF ART IS RECALLING 3 MY 2007 E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    A WORK OF ART IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR A WORK OF ART AT 1-574-537-8187.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COLONIAL EQUIPMENT COMPANY
    Manufacture Dates: -
    Potential Units Affected:50

    Defect Description:

    COLONIAL IS RECALLING 50 MY 2006-2008 FORD E350, E450, AND CHEVROLET G-VAN CUTAWAY CHASSIS VEHICLES AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    COLONIAL IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COLONIAL AT 1-301-698-5100.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COLONIAL EQUIPMENT COMPANY
    Manufacture Dates: -
    Potential Units Affected:50

    Defect Description:

    COLONIAL IS RECALLING 50 MY 2006-2008 FORD E350, E450, AND CHEVROLET G-VAN CUTAWAY CHASSIS VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    COLONIAL IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COLONIAL AT 1-301-698-5100.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:CUMMINGS MOBILITY CONVERSION & SUPPLY, I
    Manufacture Dates: -
    Potential Units Affected:42

    Defect Description:

    CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:08/01/2006 - 08/31/2012
    Potential Units Affected:37

    Defect Description:

    Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

    Consequence:

    If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.

    Action:

    Mobility Works will notify owners and Ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin July 15, 2013. Owners may contact Mobility Works at 1-877-275-4912 and Ricon at 1-818-267-3000.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Cummings Mobility Conversion & Supply, I
    Manufacture Dates:11/20/2006 - 09/10/2010
    Potential Units Affected:66

    Defect Description:

    Cummings Mobility Conversion & Supply, Inc. (Cummings) is recalling various model year 1994-2011 Ford and Chevrolet vans equipped with Braun NCL-2, and NVL-2 wheel chair lifts manufactured November 20, 2006, through September 10, 2010. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.

    Consequence:

    A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

    Action:

    Braun Corporation notified all the vehicle owners, and Cummings Mobility replaced the recalled parts with new parts, free of charge. The recall was completed as of April 10, 2014. Owners may contact Cummings customer service at 1-800-639-5438.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:New England Wheels
    Manufacture Dates:02/01/2006 - 08/31/2014
    Potential Units Affected:286

    Defect Description:

    New England Wheels (New England) is recalling certain model year 2006-2014 E-250, and E-350 vehicles modified by New England to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    New England will notify owners to take vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 17, 2014. Owners may contact New England customer service at 1-800-886-9247 or Ricon customer service at 1-800-322-2884. New England's number for this recall is 14E-041.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:01/01/2006 - 12/31/2014
    Potential Units Affected:667

    Defect Description:

    MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:New England Wheels
    Manufacture Dates:01/01/2006 - 09/30/2014
    Potential Units Affected:278

    Defect Description:

    New England Wheels is recalling certain model year 2006-2014 Ford E-250, and E-350 cargo vans modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    New England Wheels will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on January 5, 2016. Owners may contact New England Wheels customer service at 1-800-866-9247, or Ricon Customer Service at 1-800-322-2884. New England Wheels' number for this recall is 15E-068. Note: These vans and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:New England Wheels
    Manufacture Dates:01/01/2006 - 04/20/2015
    Potential Units Affected:2

    Defect Description:

    New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.

    Action:

    New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
    2007 FORD E-350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Specialists, Inc.
    Manufacture Dates:04/04/2006 - 08/07/2014
    Potential Units Affected:285

    Defect Description:

    Mobility Specialists, Inc. (Mobility Specialists) is recalling certain model year 2006-2014 Ford E-250, and E-350 vehicles modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Additionally, the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator. Additionally, if the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

    Action:

    Mobility Specialists will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 13, 2015. Owners may contact Mobility Specialists customer service at 1-877-777-5438, or Ricon customer service at 1-800-322-2884.
    2007 FORD E350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Mobility Works (WMK Inc.)
    Manufacture Dates:01/01/2006 - 10/09/2014
    Potential Units Affected:834

    Defect Description:

    Mobility Works (WMK Inc.) is recalling certain model year 2006-2014 Ford E150, E250, and E350 vans modified by Mobility Works to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Mobility Works will notify owners, and Ricon will supply supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 10, 2014. Owners may contact Mobility Works customer service at 1-800-769-8267 or Ricon customer service at 1-800-322-2884.
    2007 FORD E-350 ALLSTAR
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:STARCRAFT BUS AND MOBILITY
    Manufacture Dates:01/01/2005 - 12/31/2008
    Potential Units Affected:814

    Defect Description:

    STARCRAFT IS RECALLING 814 MY 2005-2007 FORD E-350 STARLITE, FORD E-350/E-450 ALLSTAR, AND GM 3500 ALLSTAR TRUCKS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    STARCRAFT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR STARCRAFT AT 574-642-3112.
    2007 FORD E-350 CUTAWAY
    NHTSA Campaign ID:ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
    Manufacturer:WHEELED COACH INDUSTRIES
    Manufacture Dates:07/09/2004 - 03/01/2007
    Potential Units Affected:1006

    Defect Description:

    ON CERTAIN AMBULANCES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CORROSION MAY OCCUR ON THE ANL 400 AMP FUSE DUE TO EXPOSURE TO CALCIUM CHLORIDE ELEMENTS THAT ARE USED IN THE "SALT STATES" DURING THE WINTER SEASON.

    Consequence:

    THE DETERIORATION OF THE FUSE CAN CAUSE A DISRUPTION OF POWER RESULTING IN LOSS OF SERVICE IN THE PATIENT COMPARTMENT.

    Action:

    RETROFIT KITS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO CUSTOMERS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2008. OWNERS MAY CONTACT WHEELED COACH AT 800-932-7077.
    2007 FORD E-350 STARLITE
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:STARCRAFT BUS AND MOBILITY
    Manufacture Dates:01/01/2005 - 12/31/2008
    Potential Units Affected:814

    Defect Description:

    STARCRAFT IS RECALLING 814 MY 2005-2007 FORD E-350 STARLITE, FORD E-350/E-450 ALLSTAR, AND GM 3500 ALLSTAR TRUCKS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    STARCRAFT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR STARCRAFT AT 574-642-3112.
    2007 FORD E-350 VAN
    NHTSA Campaign ID:ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
    Manufacturer:WHEELED COACH INDUSTRIES
    Manufacture Dates:06/17/2004 - 04/17/2007
    Potential Units Affected:1006

    Defect Description:

    ON CERTAIN AMBULANCES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CORROSION MAY OCCUR ON THE ANL 400 AMP FUSE DUE TO EXPOSURE TO CALCIUM CHLORIDE ELEMENTS THAT ARE USED IN THE "SALT STATES" DURING THE WINTER SEASON.

    Consequence:

    THE DETERIORATION OF THE FUSE CAN CAUSE A DISRUPTION OF POWER RESULTING IN LOSS OF SERVICE IN THE PATIENT COMPARTMENT.

    Action:

    RETROFIT KITS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO CUSTOMERS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2008. OWNERS MAY CONTACT WHEELED COACH AT 800-932-7077.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COLONIAL EQUIPMENT COMPANY
    Manufacture Dates: -
    Potential Units Affected:50

    Defect Description:

    COLONIAL IS RECALLING 50 MY 2006-2008 FORD E350, E450, AND CHEVROLET G-VAN CUTAWAY CHASSIS VEHICLES AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    COLONIAL IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COLONIAL AT 1-301-698-5100.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ELKHART COACH
    Manufacture Dates: -
    Potential Units Affected:41

    Defect Description:

    ELKHART COACH HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN TRANSIT BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

    Action:

    ELKHART COACH IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800-322-2884, EMAILING AT WWW.DMATA@WABTEC.COM.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Elkhart Coach
    Manufacture Dates:01/01/2006 - 05/01/2014
    Potential Units Affected:437

    Defect Description:

    Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT:AIR CONDITIONER
    Manufacturer:CUES, INC.
    Manufacture Dates: -
    Potential Units Affected:269

    Defect Description:

    CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

    Consequence:

    THIS DEFECT COULD RESULT IN A FIRE.

    Action:

    CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT:AIR CONDITIONER
    Manufacturer:ENG MOBILE SYSTEM, INC
    Manufacture Dates:05/01/2007 - 08/31/2009
    Potential Units Affected:53

    Defect Description:

    E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

    Consequence:

    THIS DEFECT COULD RESULT IN A FIRE.

    Action:

    E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:LA BOIT INC.
    Manufacture Dates:04/01/2006 - 12/31/2007
    Potential Units Affected:8

    Defect Description:

    LA BOIT IS RECALLING 8 MY 2006-2007 FORD E-450, GMC 5500, AND WORKHORSE SPECIALTY VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    LA BOIT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR LA BOIT AT 1-614-231-7640.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:LA BOIT INC.
    Manufacture Dates:04/01/2006 - 12/31/2007
    Potential Units Affected:8

    Defect Description:

    LA BOIT IS RECALLING 8 MY 2006-2007 FORD E-450, GMC 5500, AND WORKHORSE SPECIALTY VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    LA BOIT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR LA BOIT AT 1-614-231-7640.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:ELKHART COACH
    Manufacture Dates: -
    Potential Units Affected:200

    Defect Description:

    ELKHART COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN TRANSIT BUSES EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

    Consequence:

    WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

    Action:

    ELKHART COACH WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. CURRENTLY RICON IS DEVELOPING A SOFTWARE SOLUTION AND IS NOT AVAILABLE. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800- 322-2884, EMAILING AT WWW.DMATA@WABTEC.COM.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:Farber Specialty Vehicles
    Manufacture Dates:01/15/2007 - 07/24/2013
    Potential Units Affected:117

    Defect Description:

    Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

    Consequence:

    If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

    Action:

    Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March 24, 2015. Owners may contact Farber customer service at 1-800-331-3188, or Ricon customer service at 1-800-322-2884. Farber's number for this recall is 14E-041.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT
    Manufacturer:Creative Bus Sales, Inc.
    Manufacture Dates: -
    Potential Units Affected:227

    Defect Description:

    Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.

    Consequence:

    A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

    Action:

    Braun is conducting this recall on behalf of Creative Bus Sales. Braun will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 23, 2012. Owners may contact Creative Bus at 1-888-633-8380 or Braun at 1-800-488-0359.
    2007 FORD E-450
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COLONIAL EQUIPMENT COMPANY
    Manufacture Dates: -
    Potential Units Affected:50

    Defect Description:

    COLONIAL IS RECALLING 50 MY 2006-2008 FORD E350, E450, AND CHEVROLET G-VAN CUTAWAY CHASSIS VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    COLONIAL IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COLONIAL AT 1-301-698-5100.
    2007 FORD E-450 ALLSTAR
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:STARCRAFT BUS AND MOBILITY
    Manufacture Dates:01/01/2005 - 12/31/2008
    Potential Units Affected:814

    Defect Description:

    STARCRAFT IS RECALLING 814 MY 2005-2007 FORD E-350 STARLITE, FORD E-350/E-450 ALLSTAR, AND GM 3500 ALLSTAR TRUCKS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    STARCRAFT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR STARCRAFT AT 574-642-3112.
    2007 FORD E-450 CUTAWAY
    NHTSA Campaign ID:ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
    Manufacturer:WHEELED COACH INDUSTRIES
    Manufacture Dates:04/30/2004 - 02/17/2007
    Potential Units Affected:1006

    Defect Description:

    ON CERTAIN AMBULANCES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CORROSION MAY OCCUR ON THE ANL 400 AMP FUSE DUE TO EXPOSURE TO CALCIUM CHLORIDE ELEMENTS THAT ARE USED IN THE "SALT STATES" DURING THE WINTER SEASON.

    Consequence:

    THE DETERIORATION OF THE FUSE CAN CAUSE A DISRUPTION OF POWER RESULTING IN LOSS OF SERVICE IN THE PATIENT COMPARTMENT.

    Action:

    RETROFIT KITS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO CUSTOMERS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2008. OWNERS MAY CONTACT WHEELED COACH AT 800-932-7077.
    2007 FORD ECONOLINE
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:SUNSET VANS INC.
    Manufacture Dates:04/01/2005 - 09/30/2006
    Potential Units Affected:169

    Defect Description:

    SUNSET VANS IS RECALLING 169 MY 2005-2007 ECONOLINE, G SERIES AND SPRINTER TRUCKS BUILT ON DODGE, FORD AND CHEVROLET CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    SUNSET VANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR SUNSET VANS AT 1-888-280-8267.
    2007 FORD ECONOLINE
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:SUNSET VANS INC.
    Manufacture Dates:04/01/2005 - 10/30/2007
    Potential Units Affected:267

    Defect Description:

    SUNSET VANS IS RECALLING 267 MY 2005-2007 ECONOLINE, G SERIES AND SPRINTER TRUCKS BUILT ON DODGE, FORD AND CHEVROLET CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    SUNSET VANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR SUNSET VANS AT 1-888-280-8267.
    2007 FORD EDGE
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:08/16/2006 - 07/01/2010
    Potential Units Affected:1892343

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD EDGE
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
    Manufacturer:Ford Motor Company
    Manufacture Dates:06/15/2006 - 09/22/2008
    Potential Units Affected:186024

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.

    Consequence:

    A fuel leak in the presence of an ignition source increases the risk of a fire.

    Action:

    Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S22.
    2007 FORD EDGE
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:06/20/2006 - 06/09/2009
    Potential Units Affected:654695

    Defect Description:

    Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD ESCAPE
    NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
    Manufacturer:Ford Motor Company
    Manufacture Dates:03/31/2001 - 09/01/2009
    Potential Units Affected:57

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.

    Consequence:

    If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

    Action:

    Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
    2007 FORD ESCAPE
    NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
    Manufacturer:Ford Motor Company
    Manufacture Dates:03/31/2001 - 09/01/2009
    Potential Units Affected:57

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.

    Consequence:

    If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

    Action:

    Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
    2007 FORD ESCAPE
    NHTSA Campaign ID:HYBRID PROPULSION SYSTEM
    Manufacturer:Ford Motor Company
    Manufacture Dates:10/13/2003 - 06/20/2008
    Potential Units Affected:70209

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.

    Consequence:

    If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.

    Action:

    Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
    2007 FORD E-SERIES
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:NEW ENGLAND WHEELS
    Manufacture Dates:04/01/2005 - 10/06/2007
    Potential Units Affected:513

    Defect Description:

    NEW ENGLAND WHEELS, INC. IS RECALLING 513 RICON WHEELCHAIR LIFTS WHICH IT INSTALLED ON MY 2005 THROUGH 2007 FORD E-SERIES COMMERCIAL VANS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    NEW ENGLAND WHEELS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW ENGLAND WHEELS AT 1-800-886-9247.
    2007 FORD E-SERIES
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:NEW ENGLAND WHEELS
    Manufacture Dates:04/01/2005 - 10/30/2007
    Potential Units Affected:513

    Defect Description:

    NEW ENGLAND WHEELS IS RECALLING 513 MY 2005-2007 FORD E-SERIES VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    NEW ENGLAND WHEELS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW ENGLAND WHEELS AT 1-800-886-9247.
    2007 FORD EXPEDITION
    NHTSA Campaign ID:LATCHES/LOCKS/LINKAGES:DOORS:LATCH
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:03/03/2006 - 08/09/2007
    Potential Units Affected:123632

    Defect Description:

    FORD IS RECALLING 123,632 MY 2007-2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES. THE DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE BOTTOM OF THE INTERIOR DOOR HANDLE SPRING ON ALL SIDE DOORS MAY FRACTURE DURING NORMAL CUSTOMER USAGE. THIS CAN RESULT IN INSUFFICIENT SPRING FORCE TO RETURN THE HANDLE TO THE FULLY CLOSED POSITION. THE HANDLE MAY BE LOOSE CAUSING A RATTLE OR NOISE AND THE HANDLE MAY NOT RETURN TO THE FULLY CLOSED POSITION. THIS CONDITION MAY ALSO PROVIDE A DELAYED RESISTANCE WHEN ACTUATING THE HANDLE PRIOR TO OPENING THE DOOR.

    Consequence:

    IN THE EVENT OF A SIDE IMPACT CRASH, THE INTERIOR DOOR HANDLE MAY CAUSE THE DOOR LATCH TO OPEN INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.

    Action:

    DEALERS WILL REPLACE THE INTERIOR HANDLE SPRING ON ALL SIDE DOORS. THE RECALL BEGAN ON MARCH 5, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD EXPEDITION
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:08/14/2006 - 12/22/2006
    Potential Units Affected:57199

    Defect Description:

    FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK.

    Consequence:

    FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

    Action:

    DEALERS WILL REPLACE THE FUEL RAIL ASSEMBLY. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD EXPLORER
    NHTSA Campaign ID:STEERING
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:01/16/2007 - 03/20/2007
    Potential Units Affected:11

    Defect Description:

    ON CERTAIN SPORT UTILITY VEHICLES, THE TWO BOLTS THAT ATTACH THE STEERING GEAR ASSEMBLY TO THE FRAME MAY HAVE BEEN OVER-TIGHTENED. THIS CONDITION COULD RESULT IN ONE OR BOTH OF THE BOLTS FRACTURING, CAUSING THE STEERING GEAR TO BECOME LOOSE.

    Consequence:

    THIS CONDITION COULD CAUSE "CLUNKING" NOISE WHEN STEERING AS WELL AS DECREASED STEERING EFFECTIVENESS POTENTIALLY RESULTING IN A CRASH.

    Action:

    DEALERS WILL REPLACE BOTH THE STEERING GEAR ASSEMBLY MOUNTING BOLTS AND NUTS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD EXPLORER SPORT TRAC
    NHTSA Campaign ID:STEERING
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:02/15/2007 - 02/15/2007
    Potential Units Affected:11

    Defect Description:

    ON CERTAIN SPORT UTILITY VEHICLES, THE TWO BOLTS THAT ATTACH THE STEERING GEAR ASSEMBLY TO THE FRAME MAY HAVE BEEN OVER-TIGHTENED. THIS CONDITION COULD RESULT IN ONE OR BOTH OF THE BOLTS FRACTURING, CAUSING THE STEERING GEAR TO BECOME LOOSE.

    Consequence:

    THIS CONDITION COULD CAUSE "CLUNKING" NOISE WHEN STEERING AS WELL AS DECREASED STEERING EFFECTIVENESS POTENTIALLY RESULTING IN A CRASH.

    Action:

    DEALERS WILL REPLACE BOTH THE STEERING GEAR ASSEMBLY MOUNTING BOLTS AND NUTS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD F-150
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:05/29/2007 - 06/07/2007
    Potential Units Affected:203

    Defect Description:

    ON CERTAIN TRUCKS BUILT WITH 26 GALLON FUEL TANKS, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK (NOT VISIBLE FROM OUTSIDE THE FUEL TANK). IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR A "SERVICE ENGINE SOON" INDICATOR LIGHT.

    Consequence:

    IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

    Action:

    DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JUNE 25, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
    2007 FORD F-150
    NHTSA Campaign ID:ENGINE AND ENGINE COOLING
    Manufacturer:ROUSH PERFORMANCE PRODUCTS, INC.
    Manufacture Dates: -
    Potential Units Affected:213

    Defect Description:

    ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.

    Consequence:

    THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.

    Action:

    DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
    2007 FORD F-250
    NHTSA Campaign ID:SEATS
    Manufacturer:Vantage Mobility International, LLC
    Manufacture Dates:05/10/2018 - 05/15/2018
    Potential Units Affected:12

    Defect Description:

    Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

    Consequence:

    In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

    Action:

    Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
    2007 FORD F-250
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-250
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM TRANS SULLY CORPORATION
    Manufacture Dates:04/01/2005 - 10/30/2007
    Potential Units Affected:111

    Defect Description:

    COMM TRANS IS RECALLING 111 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.
    2007 FORD F250
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM TRANS SULLY CORPORATION
    Manufacture Dates:04/01/2005 - 09/30/2007
    Potential Units Affected:108

    Defect Description:

    COMM TRANS IS RECALLING 108 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.
    2007 FORD F-250 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-250 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-350
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-350
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM TRANS SULLY CORPORATION
    Manufacture Dates:04/01/2005 - 10/30/2007
    Potential Units Affected:111

    Defect Description:

    COMM TRANS IS RECALLING 111 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

    Consequence:

    THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

    Action:

    COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.
    2007 FORD F350
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:COMM TRANS SULLY CORPORATION
    Manufacture Dates:04/01/2005 - 09/30/2007
    Potential Units Affected:108

    Defect Description:

    COMM TRANS IS RECALLING 108 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

    Consequence:

    A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

    Action:

    COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.
    2007 FORD F-350 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-350 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-450
    NHTSA Campaign ID:TRAILER HITCHES
    Manufacturer:KNAPHEIDE MANUFACTURING COMPANY
    Manufacture Dates:10/23/2006 - 07/15/2008
    Potential Units Affected:108

    Defect Description:

    KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

    Consequence:

    THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

    Action:

    KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
    2007 FORD F-450 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-450 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-550
    NHTSA Campaign ID:TRAILER HITCHES
    Manufacturer:KNAPHEIDE MANUFACTURING COMPANY
    Manufacture Dates:10/23/2006 - 07/15/2008
    Potential Units Affected:108

    Defect Description:

    KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

    Consequence:

    THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

    Action:

    KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
    2007 FORD F-550 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-550 SD
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD F-650
    NHTSA Campaign ID:TRAILER HITCHES
    Manufacturer:KNAPHEIDE MANUFACTURING COMPANY
    Manufacture Dates:10/23/2006 - 07/15/2008
    Potential Units Affected:108

    Defect Description:

    KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

    Consequence:

    THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

    Action:

    KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
    2007 FORD F-650 SD
    NHTSA Campaign ID:POWER TRAIN:AXLE ASSEMBLY
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:11/15/2006 - 02/14/2007
    Potential Units Affected:31

    Defect Description:

    ON CERTAIN TRUCKS BUILT WITH DANA REAR AXLES, THE REAR AXLE MAY HAVE A HOUSING THAT WAS BUILT USING STEEL THAT WAS THINNER THAN SPECIFIED.

    Consequence:

    THROUGH NORMAL USE, THE AXLE HOUSING COULD FATIGUE AND DEVELOP A CRACK WHICH COULD RESULT IN A WHEEL END LOCK-UP OR SEPARATION, POSSIBLY RESULTING IN A CRASH.

    Action:

    DEALERS WILL REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-248-0186.
    2007 FORD F-750 SD
    NHTSA Campaign ID:POWER TRAIN:AXLE ASSEMBLY
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:11/15/2006 - 02/14/2007
    Potential Units Affected:31

    Defect Description:

    ON CERTAIN TRUCKS BUILT WITH DANA REAR AXLES, THE REAR AXLE MAY HAVE A HOUSING THAT WAS BUILT USING STEEL THAT WAS THINNER THAN SPECIFIED.

    Consequence:

    THROUGH NORMAL USE, THE AXLE HOUSING COULD FATIGUE AND DEVELOP A CRACK WHICH COULD RESULT IN A WHEEL END LOCK-UP OR SEPARATION, POSSIBLY RESULTING IN A CRASH.

    Action:

    DEALERS WILL REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-248-0186.
    2007 FORD FIVE HUNDRED
    NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:09/05/2006 - 09/11/2006
    Potential Units Affected:2945

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2007 FORD FIVE HUNDRED AND MERCURY MONTEGO VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH SEPTEMBER 11, 2006. THE FUEL TANKS MAY NOT HAVE CONSISTENT WELDS BETWEEN THE FUEL TANK AND FUEL FILLER NECK SPUD WHICH CAN AFFECT THE STRENGTH OF THE JOINT. SOME FUEL TANK SPUD WELDS MAY NOT PROVIDE THE EXPECTED STRENGTH IN THE EVENT OF A SEVERE REAR IMPACT TO THE VEHICLE. AN IMPROPER WELD CAN RESULT IN A CRACK IN THE JOINT WHICH COULD ILLUMINATE THE EMISSIONS MALFUNCTION INDICATOR LIGHT, CAUSE A FUEL ODOR, OR ALLOW FUEL TO LEAK OUT.

    Consequence:

    FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

    Action:

    DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD FREESTAR
    NHTSA Campaign ID:SEATS
    Manufacturer:Ford Motor Company
    Manufacture Dates:03/24/2003 - 11/07/2006
    Potential Units Affected:196667

    Defect Description:

    Ford is recalling certain model year 2004-2007 Freestar and Mercury Monterey vehicles manufactured from March 24, 2003, through November 7, 2006, equipped with a third row seat and originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. The third row stowable seat can experience corrosion and structural degradation at the seat anchor mechanism mounted to the rear wheel wells. As a result of the corrosion, the third row seat may not fully latch into its seating position.

    Consequence:

    In the event that the vehicle is crashed into from the rear, an unlatched seat may increase the risk of personal injury.

    Action:

    Ford will notify owners, and dealers will install new third row seat latch striker mounting brackets, free of charge. The recall began on March 28, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
    2007 FORD FUSION
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:03/15/2005 - 12/19/2008
    Potential Units Affected:654695

    Defect Description:

    Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD FUSION
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:05/10/2005 - 06/04/2011
    Potential Units Affected:1892343

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD GRAND MARQUIS
    NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:03/30/2007 - 04/04/2007
    Potential Units Affected:630

    Defect Description:

    CERTAIN PASSENGER VEHICLES EQUIPPED WITH ANTILOCK BRAKE SYSTEMS (ABS) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THE FRONT AND REAR RIGHT SIDE BRAKE LINES MAY BE REVERSED AT THE ABS HYDRAULIC CONTROL UNIT.

    Consequence:

    THE BRAKES MAY NOT OPERATE AS INTENDED, WHICH COULD RESULT IN A CRASH.

    Action:

    DEALERS WILL INSPECT THE BRAKE LINE CONNECTIONS AND THE HYDRAULIC CONTROL UNIT AND REPOSITION THEM FREE OF CHARGE. THE RECALLBEGAN ON APRIL 27, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
    2007 FORD LCF
    NHTSA Campaign ID:TRAILER HITCHES
    Manufacturer:KNAPHEIDE MANUFACTURING COMPANY
    Manufacture Dates:10/23/2006 - 07/15/2008
    Potential Units Affected:108

    Defect Description:

    KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

    Consequence:

    THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

    Action:

    KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
    2007 FORD MUSTANG
    NHTSA Campaign ID:AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
    Manufacturer:Ford Motor Company
    Manufacture Dates:04/06/2004 - 06/21/2014
    Potential Units Affected:1018622

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2005-2014 Mustang vehicles manufactured April 6, 2004, to June 21, 2014, and 2005-2006 GT vehicles manufactured February 20, 2004, to September 22, 2006. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

    Consequence:

    In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the front driver side air bag inflator, free of charge. The recall began on June 10, 2016. Even if interim repairs were performed under safety recall 14V-802, owners must bring their vehicles in for the final remedy. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S21. Note: This recall supersedes safety recall 14V-802.
    2007 FORD MUSTANG
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:04/06/2004 - 12/19/2008
    Potential Units Affected:654695

    Defect Description:

    Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD MUSTANG
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:07/26/2004 - 02/03/2011
    Potential Units Affected:1892343

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD MUSTANG
    NHTSA Campaign ID:AIR BAGS:FRONTAL
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates:04/22/2005 - 01/31/2008
    Potential Units Affected:434593

    Defect Description:

    FORD IS RECALLING 434,593 MY 2008 MUSTANG VEHICLES FOR FAILING TO COMPLY WITH ONE OF THE NECK INJURY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION," FOR AN UNBELTED 5TH PERCENTILE FEMALE SITTING IN THE PASSENGER SEAT WHILE IT IS IN THE FULL FORWARD POSITION.

    Consequence:

    DURING AN AIR BAG DEPLOYMENT, IF A SMALL FEMALE IN THE FRONT PASSENGER SEAT IS NOT WEARING THE SAFETY BELT, AND HAS THE SEAT IN THE FULL FORWARD POSITION, THERE MAY BE AN INCREASED POTENTIAL FOR A NECK INJURY.

    Action:

    DEALERS WILL REPROGRAM THE RESTRAINT CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH EMAIL TO WWW.OWNERCONNECTION.COM.
    2007 FORD ODYSSEY
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:TURTLE TOP
    Manufacture Dates:12/01/2007 - 12/31/2009
    Potential Units Affected:138

    Defect Description:

    TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 TRANSIT AND SHUTTLE BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE WHEELCHAIR LIFTS WERE TO BE EQUIPPED WITH A RESTRAINT BUCKLE THAT HAS AN INTERLOCK FEATURE DESIGNED TO PREVENT THE LIFT FROM OPERATING IF THE BUCKLE IS NOT LATCHED. IN THE RECALLED BUSES, HOWEVER, THE INTERLOCK FEATURE MAY NOT OPERATE PROPERLY AND THE LIFT MAY OPERATE EVEN WHEN THE BUCKLE IS NOT LATCHED.

    Consequence:

    THE WHEELCHAIR MAY MOVE DURING LIFT OPERATION AND THE UNSECURED OCCUPANT, COULD BE INJURED.

    Action:

    TURTLE TOP IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 1-800-322-2884, OR EMAIL AT WWW.DMATA@WABTEC.COM.
    2007 FORD ODYSSEY
    NHTSA Campaign ID:EQUIPMENT
    Manufacturer:TURTLE TOP
    Manufacture Dates:08/02/1999 - 09/01/2007
    Potential Units Affected:1817

    Defect Description:

    TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2001-2007 TRANSIT BUSES BUILT ON VARIOUS GM AND FORD CHASSIS FROM AUGUST 2, 1999 THROUGH SEPTEMBER 1, 2007, EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE.

    Consequence:

    THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE.

    Action:

    TRANS/AIR, IN COOPERATION WITH TURTL TOP, WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446.
    2007 FORD RANGER
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:02/20/2006 - 12/16/2011
    Potential Units Affected:1892343

    Defect Description:

    Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD RANGER
    NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
    Manufacturer:Ford Motor Company
    Manufacture Dates:01/09/2006 - 08/27/2009
    Potential Units Affected:654695

    Defect Description:

    Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

    Consequence:

    An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

    Action:

    Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
    2007 FORD RANGER
    NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD RANGER
    NHTSA Campaign ID:EXTERIOR LIGHTING:TAIL LIGHTS
    Manufacturer:FORD MOTOR COMPANY
    Manufacture Dates: -
    Potential Units Affected:26715

    Defect Description:

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence:

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    Action:

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
    2007 FORD VAN TERRA
    NHTSA Campaign ID:EQUIPMENT ADAPTIVE
    Manufacturer:TURTLE TOP
    Manufacture Dates:12/01/2007 - 12/31/2009
    Potential Units Affected:138

    Defect Description:

    TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 TRANSIT AND SHUTTLE BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE WHEELCHAIR LIFTS WERE TO BE EQUIPPED WITH A RESTRAINT BUCKLE THAT HAS AN INTERLOCK FEATURE DESIGNED TO PREVENT THE LIFT FROM OPERATING IF THE BUCKLE IS NOT LATCHED. IN THE RECALLED BUSES, HOWEVER, THE INTERLOCK FEATURE MAY NOT OPERATE PROPERLY AND THE LIFT MAY OPERATE EVEN WHEN THE BUCKLE IS NOT LATCHED.

    Consequence:

    THE WHEELCHAIR MAY MOVE DURING LIFT OPERATION AND THE UNSECURED OCCUPANT, COULD BE INJURED.

    Action:

    TURTLE TOP IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 1-800-322-2884, OR EMAIL AT WWW.DMATA@WABTEC.COM.

*Green Vehicles

Find the Ford models that are the cleanest and most fuel efficient.

  • The Green Vehicle Guide will help you find the most fuel-efficient Ford for your needs.

    California emissions requirements differ from the federal requirements, and therefore selecting ALL STATES may produce multiple listings for the same vehicle.

     

     

     

     

*Monthly Payment Calculator

Find a car or truck made by Ford that fits your budget by using our monthly payment calculator.
  • Make your selections in the boxes below and click the "Generate List" button to see a list of Ford cars and trucks that fit your monthly budget.